Need help?Do you have a question about the Kohler Courage XT-6 and is the answer not in the manual?
General| Displacement | 149 cc |
|---|---|
| Compression Ratio | 8.5:1 |
| Fuel Type | Unleaded gasoline |
| Starter Type | Recoil |
| Engine Type | 4-Cycle, OHV, Single Cylinder |
| Oil Capacity | 0.6 L (20 fl. oz.) |
| Ignition System | Electronic |
| Fuel Tank Capacity | 1.1 L (37 fl. oz.) |
Warning about explosive fuel and potential fires or severe burns. Do not fill tank while hot or running.
Caution regarding hot engine parts. Avoid touching during or immediately after operation.
Warning about lethal exhaust gases causing nausea, fainting, or death. Never run engine in confined areas.
Caution about accidental starts causing severe injury or death. Disconnect spark plug lead before servicing.
Warning about electrical shock hazards. Do not touch wires while the engine is running.
Warning about rotating parts causing severe injury. Keep clear of all moving parts.
Engine exhaust contains chemicals known to cause cancer, birth defects, or reproductive harm.
Use high-quality oil ranking at or above API SJ service class. Select viscosity based on air temperature.
Purchase gasoline in small quantities, store in approved containers. Use fresh fuel, do not overfill.
Use clean, fresh, unleaded gasoline with 87 octane or higher. Unleaded is recommended.
Gasohol (up to 10% ethyl alcohol) is approved. Other blends like E20/E85 are not.
MTBE and unleaded gasoline blends up to 15% MTBE are approved. Other blends are not.
Use Low Permeation SAE 30 R7 rated fuel lines. Order replacements from authorized centers.
Instructions for turning the fuel shut-off valve ON or OFF. Ensure it's OFF before transporting.
Engine ID numbers are on labels. Record model, spec, and serial numbers for reference.
Serial number is etched on the engine block below the fuel tank. Record for future reference.
Details the engine's operating hours for meeting Federal and CARB emission requirements.
Steps to perform before starting the engine: check oil, fuel, cooling areas, and guards.
Tips for starting in cold weather: use winter grade fuel, ensure battery is good, and use proper oil.
Instructions for starting engines with Smart-Choke. No adjustments are necessary or possible.
Procedure for starting the engine using the electric start system on XTR-7 models.
Procedure for starting the engine using the manual recoil starter handle.
Instructions for using the primer bulb to start the engine, depending on temperature.
Procedure for starting a cold engine using the manual choke lever.
Provides a schedule for required maintenance tasks based on operating hours or time intervals.
Instructions for checking and replacing the paper air filter. Do not wash or use compressed air.
Instructions for checking and replacing the foam air filter. Use genuine Kohler parts.
Instructions for washing or replacing the optional precleaner with detergent and warm water.
To Next Page
