Krone Comprima V 150 - Page 8

Contents
6
9.4.2 General Information ............................................................................................. IX -16
9.4.3 Tensioning the Drive Chains ............................................................................... IX -17
9.4.3.1 Front Floor Conveyor Drive ................................................................................. IX -17
9.4.3.2 Rear Floor Conveyor Drive
(COMPRIMA V150, V180).................................................................................. IX -17
9.4.3.3 Roller Drive ......................................................................................................... IX -18
9.4.3.4 Cutting Roller, Feed Rotor, Pick-up ..................................................................... IX -19
9.4.3.5 Main Pick-up Drive / Pick-up Drive...................................................................... IX -20
9.4.3.6 Left Auger Conveyor Drive .................................................................................. IX -20
9.5 Hydraulic System ................................................................................................ IX -21
9.5.1 Special Safety Instructions .................................................................................. IX -21
9.5.2 General Information ............................................................................................. IX -21
9.5.3 Solenoid Valves................................................................................................... IX -22
9.5.4 Replacing the Hydraulic Fluid Filter (COMPRIMA V150/180) ............................. IX -23
9.5.5 Hydraulic Circuit Diagram (Comprima F125/F155) ............................................. IX -24
9.5.6 Hydraulic Circuit Diagram (Comprima V150/V180) ............................................. IX -25
9.6 Drawbar Ring Hitch ............................................................................................. IX -26
9.7 Sharpen Cutting System Blades ......................................................................... IX -26
9.8 Maintaining the Compressed Air Brake System (Special Equipment)................. IX -26
9.8.1 Service Line Hose Couplers
(Non-Reversible) ................................................................................................. IX -26
9.8.2 Air Filter for Piping............................................................................................... IX -27
9.8.3 Compressed Air Reservoir .................................................................................. IX -27
9.8.4 Drain Valve (Manually Operated)......................................................................... IX -27
9.9 Lubrication........................................................................................................... IX -28
9.9.1 Special Safety Instructions .................................................................................. IX -28
9.9.2 PTO Shaft ............................................................................................................ IX -28
9.9.3 Lubricating points (COMPRIMA F 125, F155) ..................................................... IX -29
9.9.4 Lubricating points (COMPRIMA V150, V180) ..................................................... IX -30
10 Winter Storage.................................................................................. X -1
10.1 General Information ................................................................................................ X -1
11 Return to Service ............................................................................ XI -1
11.1 General Information ............................................................................................... XI -1
11.2 Vent Overload Coupling on the PTO Shaft ............................................................ XI -2
12 Faults – Causes and Remedy ...................................................... XII -1
12.1 General Faults, Causes and Remedy................................................................... XII -1
12.2 Faults, Causes and Remedy in the Central Chain Lubrication Device ................. XII -4