KTM 500 EXC-F Six Days 2020 User Manual (English)

Other manuals for KTM 500 EXC-F Six Days 2020

Questions and Answers:

M
michael52Aug 17, 2025
What to do if KTM Motorcycle engine turns but does not start?
- T
  Tracy PettyAug 18, 2025
  If your KTM Motorcycle engine turns over but doesn't start, it could be due to an operating error (ensure you're following the correct start procedure). Other potential reasons: the fuel hose connection isn't connected (connect it), fuse 1 or 4 is blown (replace the fuses), idle speed is not set correctly (adjust it), the spark plug is oily or wet (clean and dry it, or replace it), the spark plug gap is too wide (adjust it to 1.0 mm), the ignition system is defective (check it), there's a short-circuit cable in the wiring harness, or the switch-off button or emergency OFF switch is faulty (check the wiring harness and electrical system). Also, there might be an error in the electronic fuel injection (read the fault memory using the KTM diagnostics tool).
D
David SimmonsAug 20, 2025
Why does my KTM Motorcycle engine have too little power?
- S
  sarahloweryAug 20, 2025
  If your KTM Motorcycle engine has reduced power, the air filter might be heavily contaminated (clean the air filter and air filter box). Other possible causes are a very dirty fuel filter (change the fuel filter), a very dirty fuel screen (change the fuel screen), an error in the electronic fuel injection (read the fault memory using the KTM diagnostics tool), a leaky or deformed exhaust system, or too little glass fiber yarn filling in the main silencer (check the exhaust system for damage and change the glass fiber yarn filling of the main silencer). Also, the valve clearance could be too little (adjust the valve clearance), or the ignition system could be defective (check the ignition coil secondary winding, spark plug connector, and alternator stator winding).
L
laura16Aug 22, 2025
What to do if my KTM 500 EXC-F Six Days 2020 engine does not speed up?
- C
  Christopher JonesAug 22, 2025
  If your KTM Motorcycle engine does not speed up, there could be an error in the electronic fuel injection (read out the fault memory using the KTM diagnostics tool). Another possibility is a defective ignition system (check the ignition coil secondary winding, spark plug connector, and alternator stator winding).
C
chavezjoshuaAug 25, 2025
What to do if my KTM Motorcycle dies during the trip?
- K
  Kendra JohnsonAug 26, 2025
  If your KTM Motorcycle engine dies during a trip, it might be due to a lack of fuel (refuel). Another cause could be a blown fuse 1 or fuse 4 (change the fuses).
V
Vernon SmithAug 27, 2025
What to do if my KTM 500 EXC-F Six Days 2020 engine cannot be cranked?
- M
  Michelle Moore DDSAug 28, 2025
  If your KTM Motorcycle engine won't crank, possible causes include an operating error (ensure you're following the correct start procedure). Other potential issues are a discharged 12-V battery (charge it, and check the charging voltage, open-circuit current, and alternator stator winding), a blown main fuse (replace it), a defective starter relay (check it), or a defective starter motor (check it).
P
phelpsdevinAug 30, 2025
What to do if my KTM 500 EXC-F Six Days 2020 Motorcycle engine overheats?
- R
  Raymond WilliamsAug 30, 2025
  If your KTM Motorcycle engine is overheating, it could be due to a low coolant level in the cooling system (check the cooling system for leaks and check the coolant level). Other possible reasons include insufficient airflow (switch off the engine when stationary), very dirty radiator fins (clean them), foam formation in the cooling system (drain and refill the coolant), a bent radiator hose (change it), or a defective thermostat (check the thermostat; the guideline opening temperature is 70 °C).
K
Kevin MolinaSep 1, 2025
Why does my KTM Motorcycle have high oil consumption?
- S
  smithandreSep 2, 2025
  High oil consumption in your KTM Motorcycle can be caused by several factors: a bent engine vent hose (route the vent hose without bends or replace it), an engine oil level that is too high (check the engine oil level), engine oil that is too thin (change the engine oil and oil filter, and clean the oil screens), or worn piston and cylinder (measure the piston/cylinder mounting clearance).
P
Paul KochSep 4, 2025
What does it mean if Malfunction indicator lamp lights up or flashes on my KTM Motorcycle?
- C
  Christopher AllisonSep 4, 2025
  If the malfunction indicator lamp lights up or flashes on your KTM Motorcycle, it indicates an error in the electronic fuel injection. Stop the motorcycle and identify the faulty component using the blink code. Check the wiring for damage and electrical plug-in connectors for corrosion and damage. Read out the fault memory using the KTM diagnostics tool.
N
nicholasdiazSep 6, 2025
Why is my KTM 500 EXC-F Six Days 2020 12-V battery discharged?
- M
  madisonmckenzieSep 6, 2025
  If your KTM Motorcycle's 12-V battery is discharged, it could be because the alternator is not charging it (check the charging voltage and the alternator's stator winding). Another possible cause is an undesired power consumer (check the open-circuit current).
K
Kyle GarciaSep 9, 2025
Why are the high beam, low beam, tail light, position light, and license plate lamp not working on my KTM 500 EXC-F Six Days 2020?
- S
  Susan StricklandSep 9, 2025
  If the high beam, low beam, tail light, position light, and license plate lamp are not working on your KTM Motorcycle, it is likely due to a blown fuse 2. Replace the fuse.

KTM 500 EXC-F Six Days 2020 Specifications

General

Displacement	510.4 cc
Bore x Stroke	95 mm x 72 mm
Transmission	6-speed
Starter	Electric Starter
Cooling System	Liquid cooled
Dry Weight	106.5 kg
Seat Height	960 mm
Ground Clearance	355 mm
Engine Type	Single cylinder, four-stroke
Fuel System	Electronic Fuel Injection
Front Suspension	WP XPLOR, Ø 48 mm
Rear Suspension	WP XPLOR PDS
Front Brake	Disc brake 260 mm
Rear Brake	Disc brake 220 mm
Frame	Central tube frame made of chrome molybdenum steel