G-5
35 Series 4WD, Model - 3535, 4035, 4535 and 5035 SM June’08
TROUBLE PROBABLE CAUSE REMEDY REF.
1. CHECKING ELECTRICAL TROUBLES (Contd.)
7. Charge indicator
glow dim
3. If the bulb does not light even
grounding ‘A’ terminal the cause
are.
a) Blown fuse. Check the short circuit if
any in the wiring harness
replace fuse after
rectifying the short fault.
b) Short circuited warning lamp Replace Holder.
holder
1. Regulator defective 1. Replace regulator.
2. Rotor defective 2. Replace rotor
STARTER
1. Starter 1. Faulty batteries / discharged. 1. Recharge or install new
will not operate battery.
2. Cables and terminals defective. 2. Check earth cable,
battery to starter cable,
and batteries connecting
cable for secure mounting
to terminals. Replace
cables if necessary.
3. Starter relay defective. 3. Replace
4. Safety switch defective / Safety 4. Replace
interlock not working.
a) P.T.O. Relay / PTO flahser a) Check if it is not ok,
replace
b) Neutral switch b) Check and replace
if not OK.
5. Internal damage to starter 5. Repair or replace
motor (solenoid switch should
be heard to click).
6. P.T.O. Relay faulty 6. Replace
7. Wiring harness disconnected or 7. Repair or replace
improperly connected.
8. Start motor defective. 8. Repair or replace
9. Main switch defective. 9. Replace
10.
Starter motor pilot switch out
10.
Replace or readjust
of adjustment or defective. switch.
11.
Starter motor solenoid switch
11.
Replace switch.
defective.
Electrical System
To Next Page
Loading...
Need help?
General
