Mahindra 700624-2 User Manual

15
TROUBLESHOOTING
*Pleaserefertopartsbreakdownsectionforpartsidentification.
PROBLEM POSSIBLECAUSES CORRECTIVEACTION
Snowblowervibratesoris Damagedpulley. Replacepulley.
abnormallynoisy.
Damageddriveshaft. Replacedriveshaft.
Damagedbearing. Replacebearing.
Damagedfan. Dismount&repairorreplacefan.
Drivelineisnotwellinstalled. Reinstall the driveline according to the
instructionsinStep3.
Oneorbothsectionsoftheauger
isbent.
Replaceoneorbothsectionsofauger.
Oneorbothsectionsoftheauger
havestoppedturning.
Shearboltisprobablybroken. Replace shear bolt (for identification,
see Parts List "Snowblower"). Also see
"Maintenance"section.
Snowblowerstoppedturning. Thebeltisdamagedorsnapped. Check & replace damaged belt (see
instructionsinsection:Beltreplacement
&adjustments.
Damageddriveshaft. Replacedriveshaft.
Beltiswornataspecificpoint. Snowblower was engaged when
alreadyplugged.
Makesureauger&fanarenotplugged
orfrozenbeforeengagingsnowblower.
Chuterotationisdifficult. Dirtoricemaybeunderneath
chute.
Cleanthebaseofchute&therotation
ring.
Thebaseofthechuteorthe
rotationringmaybedamagedor
bent.
Replacedefectiveparts.
Thechuteplugseasily. Vehicle engine is turning too
slowly.
AlwayshaveengineatfullR.P.M.when
usingthesnowblower.
Advancing too quickly with
vehicle.
Reduce speed. Allow snowblower to
ingestsnowatitsownspeed.
Snowblowerdigsintoground. Groundisnotfrozenortoosoft. Adjust skid shoes lower so they may
bettersupportthesnowblower.
Snowblower does not raise
evenly.
Uneven tire pressure from one
sidetoanother.
Refertothevehicle’sownermanualfor
tirepressure.
Checkandadjusttractortirepressure.
Tire pressure must be even on both
sidesofvehicle.
Snowblower raises or lowers too
slowly.
Dirtintheoil. Changethehydraulicoil.
Damagedbushing Replacethebushing.

Mahindra 700624-2 Specifications

General

Brand	Mahindra
Model	700624-2
Category	Snow Blower
Language	English