EasyManua.ls Logo

Majestic 33LDVR - User Manual

Majestic 33LDVR
48 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Installation Instructions and
Homeowner’s Manual
10007317 1/13 Rev. 17
Builder Rear Vent Direct Vent
Models: 33LDVR, 36LDVR,
39LDVR, 43LDVR
DO NOT STORE OR USE
GASOLINE OR OTHER
FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF THIS
OR ANY OTHER APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electric switch; do
not use any phone in your building.
• Immediately call your gas supplier
from your neighbor’s phone. Follow
the gas suppliers instructions.
• If you cannot reach your gas
supplier call the re department.
WARNING!
IF THE INFORMATION IN THIS
MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION
MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL
INJURY OR LOSS OF LIFE.
PLEASE READ THIS MANUAL
BEFORE INSTALLING AND USING
APPLIANCE
INSTALLER/CONSUMER
SAFETY INFORMATION
FOR YOUR SAFETY
Installation and service must be
performed by a qualied installer,
service agency or the gas supplier.
-
Ê
,
/
Ê
7317
LDVR COVER
1/05
 ,/  
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.

Table of Contents

Questions and Answers

  • A
    Alexis RosarioAug 9, 2025
    Why does my Majestic Indoor Fireplace pilot light keep going out?
    • R
      reginarussellAug 9, 2025
      Frequent pilot outages in your Majestic Indoor Fireplace can be caused by: * **Pilot flame issues:** The pilot flame might be too low or too high, causing the pilot safety to shut off the gas supply. In this case, you should clean and adjust the pilot flame for maximum flame impingement on the thermopile and thermocouple. * **Vent terminal blockage:** Check the vent terminal for any obstructions that might be recycling the flue gases.
  • S
    stevenpowersAug 16, 2025
    What to do if the pilot will not stay lit on my Majestic Indoor Fireplace?
    • V
      Victoria ClarkAug 16, 2025
      If the pilot light won't stay lit on your Majestic Indoor Fireplace after following the lighting instructions, consider these potential causes: * **Defective pilot generator (thermocouple) or remote wall switch:** Check the pilot flame to ensure it properly impinges on the thermocouple/thermopile. Clean and/or adjust the pilot for maximum flame impingement on the thermopile and thermocouple. * **Defective automatic valve:** Turn the valve knob to the “Pilot” position. While maintaining gas flow to the pilot, a millivolt meter should read greater than 10 mV. If the reading is okay but the pilot still doesn't stay lit, the gas valve needs to be replaced. Note: An interrupter block (not supplied) must be used to conduct this test.
  • M
    Matthew SimsAug 25, 2025
    How to fix a spark ignitor that will not light on a Majestic 33LDVR?
    • M
      Miguel AlvarezAug 25, 2025
      If the spark ignitor on your Majestic Indoor Fireplace isn't lighting, here's what to check: * **Defective or misaligned electrode:** First, try lighting the pilot with a match. If it lights, turn off the pilot and try the ignitor button again. If the pilot still won't light, check the gap at the electrode and pilot. It should be 1/8” to ensure a strong spark. * **Defective ignitor (push button):** Push the Piezo Ignitor Button and check for a spark at the electrode and pilot. If there's no spark and the electrode wire is properly connected, replace the ignitor.
  • L
    Lisa GravesNov 1, 2025
    What to do if the pilot is burning, but no gas to the main burner in my Majestic Indoor Fireplace?
    • C
      cmckeeNov 1, 2025
      If the pilot light is on but the main burner isn't receiving gas, there are several potential causes: * **Wall switch or wiring issues:** Inspect the wall switch and wiring for secure connections. You can test the switch by using a jumper wire across the terminals. If the burner ignites, the wall switch is faulty and needs replacement. If the switch is fine, try using a jumper wire across the wall switch wires at the valve. If the burner then comes on, the wires are faulty or the connections are bad. * **Insufficient millivoltage from the thermopile:** Ensure that the wire connections from the thermopile to the gas valve terminals are secure and that the thermopile is fully inserted into the pilot bracket. Check for a ground in one of the wall switch wires. If the pilot stays lit afte...

Summary

Installer;Consumer Safety Information

Installation & Operating Instructions

Requirements for the Commonwealth of Massachusetts

Specific installation and safety requirements mandated by Massachusetts state law for gas-fired equipment.

Installation of Carbon Monoxide Detectors

Mandatory installation guidelines for carbon monoxide detectors with side wall horizontally vented gas fueled equipment.

Manufacturer Requirements

Guidelines for manufacturers regarding venting systems provided with horizontal vent gas appliances.

Fireplace Dimensions

Locating Your Fireplace

Clearance to Combustibles

Specifies minimum safe clearances between the appliance and combustible materials.

Mantels

Guidelines for installing combustible and noncombustible mantels above the fireplace.

Hearth

Framing and Finishing

Gas Specifications

Details gas input ratings, fuel types, and control specifications for different models.

Air Shutter Adjustment

Provides guidance on adjusting the air shutter based on gas type and model.

High Elevations

Gas Line Installation

Remote ON;OFF Switch

EB-1 Electrical Box

Electronic Gas Control Valve

General Venting

Location of Vent Termination

Guidelines for the proper placement of vent terminations to ensure safety and performance.

General Venting Information - Termination Location

Termination Clearances

General Information Assembling Vent Pipes

Flex Vent Pipes

Instructions for connecting and sealing flex vent pipes using high temperature sealant.

Twist Lock Pipes

How to Use the Vent Graph

Rear Wall Venting Applications

Rear Wall Installation Twist Lock Pipe

Rear Wall Vent Installations - Flex Vent Pipe

Vertical Sidewall Applications

Vertical Sidewall Installation

Below Grade Installations

Vertical Through-the-Roof Applications

Vertical Through-the-Roof Installation

Venting Components

Operating Instructions

Glass Information

Guidelines for using and handling approved replacement glass for the fireplace.

Glass Cleaning

Instructions on how to clean the fireplace glass, including recommended frequency.

Installation of Logs, Lava Rock & Ember Material

Log Installation

Step-by-step instructions for correctly placing logs, lava rock, and ember material.

Flame & Temperature Adjustment

Flame Characteristics

Guidance on checking and comparing pilot and burner flame appearance.

Lighting and Operating Instructions

Lighting Instructions

Step-by-step guide for safely lighting the pilot and operating the fireplace.

To Turn Off Gas To Heater

Procedure for safely shutting off the gas supply to the fireplace.

Troubleshooting the Gas Control System

Troubleshooting

American Flame Gas Control System

Troubleshooting specific issues related to the American Flame Gas Control System.

American Flame Gas Control System Error Codes

Fuel Conversion Instructions

Valve Conversion

Instructions for converting the gas valve from Natural Gas to Propane and vice versa.

Maintenance

Burner and Burner Compartment

Guidance on cleaning the burner and its compartment to ensure proper operation.

Cleaning the Standing Pilot Control System

Procedure for cleaning and inspecting the standing pilot control system components.

Optional Accessories Available

Fan Kits

Information on auxiliary fan systems (FK24/FK12) to improve air circulation and efficiency.

Wiring Instructions

Ceramic Refractory Panels

Details on installing ceramic refractory panels as an optional aesthetic upgrade.

Remote Controls

Overview of optional remote control units for appliance functions.

Optional Trim Kits

Screen Door Kit

Details on available screen door kits for the appliance.

Filigree Louvre Kit

Information on filigree louvre kits for decorative enhancement.

Arch;Square Face Kit

Details on optional arch or square face kits for appliance customization.

LIMITED LIFETIME WARRANTY

Lifetime Warranty

Components covered under the lifetime warranty, subject to proof of purchase.

Five Year Warranty

Components covered under the five-year warranty, subject to proof of purchase.

Basic Warranty

Covers components for two years against manufacturing defects, including labor costs.

EnerGuide

Majestic 33LDVR Specifications

General IconGeneral
Model33LDVR
EfficiencyUp to 70%
Log Set IncludedYes
Vent TypeDirect Vent
FinishBlack
TypeFireplace
Fuel TypeGas
Viewing Area33 inches

Related product manuals