3 - 4
LUBRICANTS AND FUEL
(*) FUEL SPECIFICATION
CETANE RATING : 45 minimum
VISCOSITY : 2 - 4,5 Centistokes at 40° C
DENSITY : 0,820 - 0,860 kg/litre
SULPHUR : 0,2 % mass maximum
DISTILLATION : 85 % at 350° C
- The cetane rating is a measure of the ignition quality of a diesel fuel. A fuel with a low cetane index may cause
problems with cold starts and affect combustion.
- Viscosity is the resistance to flow. If the viscosity is outside the limits, engine performance may be affected.
- A low density reduces the power of the engine, a high density increases the power of the engine and the exhaust
fumes.
- A high sulphur content (Not usually found in europe, north america or australasia) may cause wear to the engine. If
only fuels with a high sulphur content are available, it is necessary to use a highly alkaline greasing oil in the engine or
to replace the greasing oil more frequently.
- Distillation : this indicates the mixture of different hydrocarbons in the fuel. A high ratio of light hydrocarbons can affect
the characteristics of combustion.
- Fuels for low temperatures : special winter fuels may be available for use in the engine at temperatures below 0°C.
These fuels have a lower viscosity and thus reduce the formation of paraffin in the fuel at low temperatures. The
formation of paraffin can prevent filtration of the fuel.
DIAGNOSTIC ANALYSIS OF OIL
In the event of a maintenance or service contract with the dealer you may be requested to provide a sample of a
selected component's oil, for diagnostic analysis.
ORGANS TO BE LUBRICATED CAPACITY RECOMMENDATION PACKAGING REFERENCE
I.C. ENGINE 5 L. Oil MANITOU 5 L. 581 847
Engine PLUS SAE 15W / 40 25 L. 581 842
55 L. 581 843
209 L. 581 844
FRONT WHEEL REDUCERS 1,1 L. Oil MANITOU 2 L. 499 237
Mechanical transmission for 25 L. 161 585
axles and box SAE 80W90 55 L. 546 221
209 L. 546 220
HYDRAULIC OIL TANK 95 L. Oil MANITOU 25 L. 161 588
Hydraulic ISO 46 55 L. 546 108
209 L. 546 109
MAST LIFTING CHAINS Engine oil
GREASING WITH WIELAND RINGS Grease MANITOU 1 Kg. 161590
Multigrease NLGI 2
GENERAL GREASING Grease MANITOU 1 Kg. 554 973
Multigrease HD NLGI 2 5 Kg. 554 974
COOLING CIRCUIT 11 L. Cooling liquid 2 L. 473 076
(Protection - 30 °C) 5 L. 470 077
20 L. 470 078
210 L. 470 079
Cooling liquid 2 L. 554 002
(Protection - 25 °C) 5 L. 554 003
20 L. 554 004
210 L. 554 005
FUEL TANK 73,5 L. Diesel fuel