MAULE MX-7-180B - Section III Normal Procedures; Preflight Inspection

SECTION III
NORMAL PROCEDURES:
3.1
PREFLIGHT INSPECTION:
A. INTERIOR:
1.
BAT Switch…………………………………....
2.
Fuel Gauges……………………………….….
3.
Auxiliary Fuel Pumps………………………...
4. All
Electrical Switches…………………….….
5.
BAT Switch………………………………….…
6.
Flaps……………………………………….…..
EXTERIOR:
Begin at the left front door, proceed around the left wing to the nose area, then
around the right wing and back
1.
Fuel drains behind step……………………....
2.
Left Flap………………………………………..
3.
Aileron………………………………………….
4. Left Wing
Top………………………………….
5.
Left Wing Main Fuel Tank Drain….…
Left Wing Aux Fuel Tank Drain (if installed).
6.
Left Wing Tip & Nav Light…………………....
7. Auxiliary Fuel
Tank (if installed)....................
8.
Landing Light…………………………………..
9.
Left Wing Tiedown…………………………….
10.
Pitot Tube………………………………..…….
11.
Stall Warning Switch…………………..……..
12.
Main Fuel Tank………………………….….…
13.
Left Landing Gear………………………….…
14.
Bottom left side of Cowl…………………..….
15. Top Cowl,
Oil Access Door……………….…
16.
Propeller………………………………………..
17.
Air Inlets…………………………………….….
*(3rd NOTCH) for s/n's 22003C, 22006C and
FAA APPROVED: 7/12/93
Rev. B dated:
MAULE AEROSPACE TECHNOLOGY, INC.
AIRPLANE FLIGHT MANUAL
NORMAL PROCEDURES:
PREFLIGHT INSPECTION:
BAT Switch…………………………………....
ON
Fuel Gauges……………………………….….
CHECK INDICATIONS
Auxiliary Fuel Pumps………………………...
ON, THEN OFF (LISTEN TO VERIFY
OPERATION)
Electrical Switches…………………….….
OFF
BAT Switch………………………………….…
OFF
Flaps……………………………………….…..
FULL DOWN (4TH NOTCH)*
Begin at the left front door, proceed around the left wing to the nose area, then
around the right wing and back
to the fuselage, then around the tail section.
Fuel drains behind step……………………....
DRAIN (2)
Left Flap………………………………………..
CHECK HINGES & CONTROL
ATTACHMENTS
Aileron………………………………………….
CHECK HINGES & CONTROL
ATTACHMENTS
Top………………………………….
CHECK FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
Left Wing Main Fuel Tank Drain….…
Left Wing Aux Fuel Tank Drain (if installed).
DRAIN (1)
DRAIN (1)
Left Wing Tip & Nav Light…………………....
CHECK FOR DAMAGE
Tank (if installed)....................
VISUALLY CHECK QUANTITY
Landing Light…………………………………..
CHECK FOR DAMAGE
Left Wing Tiedown…………………………….
REMOVE
Pitot Tube………………………………..…….
REMOVE COVER
Stall Warning Switch…………………..……..
CHECK FOR
FREEDOM OF
MOVEMENT
Main Fuel Tank………………………….….…
VISUALLY CHECK QUANTITY
Left Landing Gear………………………….…
CHECK TIRE INFLATION AND
BRAKE LINE SECURITY
Bottom left side of Cowl…………………..….
DRAIN GASCOLATOR (1)
Oil Access Door……………….…
CHECK OIL QUANTITY
Propeller………………………………………..
CHECK LEADING EDGE FOR
DAMAGE.
Air Inlets…………………………………….….
CHECK FOR FOREIGN OBJECTS,
INSPECT VISIBLE CONNECTIONS
AND COMPONENTS
*(3rd NOTCH) for s/n's 22003C, 22006C and
22007C unless Mod Kit No. 11 c/w .
PAGE 7
MAULE AEROSPACE TECHNOLOGY, INC.
AIRPLANE FLIGHT MANUAL
MAULE MX-7-180B
SECTION III
NORMAL
CHECK INDICATIONS
ON, THEN OFF (LISTEN TO VERIFY
FULL DOWN (4TH NOTCH)*
Begin at the left front door, proceed around the left wing to the nose area, then
to the fuselage, then around the tail section.
CHECK HINGES & CONTROL
CHECK HINGES & CONTROL
CHECK FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
CHECK FOR DAMAGE
VISUALLY CHECK QUANTITY
CHECK FOR DAMAGE
REMOVE COVER
FREEDOM OF
VISUALLY CHECK QUANTITY
CHECK TIRE INFLATION AND
BRAKE LINE SECURITY
DRAIN GASCOLATOR (1)
CHECK OIL QUANTITY
CHECK LEADING EDGE FOR
CHECK FOR FOREIGN OBJECTS,
INSPECT VISIBLE CONNECTIONS
AND COMPONENTS
SECTION III
NORMAL
PROCEDURES