MAULE MX-7-180B - Operating Check Lists

MAULE AEROSPACE TECHNOLOGY, INC.
3.1
PREFLIGHT INSPECTION:
18. Right Landing
Gear……………………….….
19.
Right Wing & Controls…………………….….
20.
Wing Main Fuel Tank Drain……….…
Wing Aux Fuel Tank Drain (if installed).........
21. Right
Fuselage, Side, Top & Bottom……….
22.
Right Side Static Port………………………...
23.
Right Stabilizer…………………………….….
24.
Right Elevator………………………………....
25.
Rudder………………………………………....
26.
Tailwheel……………………………………....
27.
Left Elevator…………………………………...
28. Left
Stabilizer……………………………….…
29.
Left Fuselage, Side, Top & Bottom………...
30.
Left Side Static Port……………………….….
3.2
OPERATING CHECK LISTS:
A.
BEFORE STARTING:
1.
Seat Belts & Shoulder Harnesses…………..
2.
Flaps……………………………………………
3.
Circuit Breakers………………………………..
B. STARTING:
1.
Parking or Toe Brakes……………………..…
2.
Fuel Selector Valve…………………………...
3.
Throttle………………………………………….
4.
Propeller Control............................................
5.
Mixture Control...............................................
6. Anti-
Collision Light………………………….....
7.
BAT and ALT Switch......................................
8.
Primer.............................................................
FAA APPROVED
DATE:
MAULE AEROSPACE TECHNOLOGY, INC.
AIRPLANE FLIGHT MANUAL
MAULE MX-7-180B
PREFLIGHT INSPECTION:
(Cont'd)
Gear……………………….….
CHECK TIRE INFLATION & BRAKE
LINE SECURITY
Right Wing & Controls…………………….….
INSPECT SAME AS LEFT WING
Wing Main Fuel Tank Drain……….…
...........
Wing Aux Fuel Tank Drain (if installed).........
DRAIN (1)
DRAIN (1)
Fuselage, Side, Top & Bottom……….
INSPECT FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
Right Side Static Port………………………...
CLEAR
Right Stabilizer…………………………….….
CHECK ATTACHMENT POINTS &
STRUT
Right Elevator………………………………....
CHECK HINGE POINTS
Rudder………………………………………....
CHECK HINGE POINTS, CONTROL
ATTACHMENT & NAV LIGHT
Tailwheel……………………………………....
CHECK FOR INFLATION,
ATTACHMENTS, REMOVE TIEDOWN
Left Elevator…………………………………...
CHECK TAB CONTROLS & ALL
HINGE POINTS
Stabilizer……………………………….…
CHECK ATTACHMENT POINTS &
STRUT
Left Fuselage, Side, Top & Bottom………...
CHECK FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
Left Side Static Port……………………….….
CLEAR
OPERATING CHECK LISTS:
BEFORE STARTING:
Seat Belts & Shoulder Harnesses…………..
FASTENED
Flaps……………………………………………
RETRACTED
Circuit Breakers………………………………..
CHECK
Parking or Toe Brakes……………………..…
ON
Fuel Selector Valve…………………………...
ON FULLEST TANK, OR BOTH IF
SAME QUANTITY
Throttle………………………………………….
OPEN 1/4 INCH
Propeller Control............................................
FULL INCREASE RPM
Mixture Control...............................................
RICH (SEE NOTE NEXT PAGE FOR
HOT START)
Collision Light………………………….....
ON
BAT and ALT Switch......................................
ON
Primer.............................................................
AS REQUIRED
PAGE 8
SECTION III
NORMAL
PROCEDURES
CHECK TIRE INFLATION & BRAKE
INSPECT SAME AS LEFT WING
INSPECT FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
CHECK ATTACHMENT POINTS &
CHECK HINGE POINTS
CHECK HINGE POINTS, CONTROL
ATTACHMENT & NAV LIGHT
CHECK FOR INFLATION,
ATTACHMENTS, REMOVE TIEDOWN
CHECK TAB CONTROLS & ALL
CHECK ATTACHMENT POINTS &
CHECK FOR WRINKLES AS
INDICATION OF INTERNAL DAMAGE
ON FULLEST TANK, OR BOTH IF
SAME QUANTITY
FULL INCREASE RPM
RICH (SEE NOTE NEXT PAGE FOR