Maxeon MAX3 User Manual


MAXEONSOLARTECHNOLOGIES,LTD.
SafetyandInstallationInstructions‐Document544753Rev.A


©2022MaxeonSolarTechnologies,Ltd.Allrightsreserved.Specificationsincludedintheseinstructionsaresubjecttochangewithoutnotice.Page|5
onthefrontglass.Neverliftormovethemoduleusingthecablesorthejunction
boxunderany‐circumstances.
Systemenergizationandshutdownproceduresnee d tobefollowedbasedon
respectiveNationalguidelinesandlocalregulations.Safesiteoperational
practicesmustbeadheredbeforeenergizingthePVsystem(e.g.electrical

continuity,avoidingdirectcontactwithelectrical/framingequipment,wearing
safetyPPE,etc.).Systemshouldbeelectricallydisconnectedduringmaintenance,
upgrades,andmodificationworkswhichcanaffecttheoperationofPVsystem.
Systemsshouldbedisconnectedinanycasesofmainte nancewhichcancause
shading(e.g.chimneysweeping,anyroofmaintenance,antenna/dish
installations,etc).

6.0MaintenanceandCleaning
TrainedMaxeondealerortrainedMaxeonsupportpersonnelshouldinspectall
modulesannuallyforsafeelectricalconnections,soundmechanicalconnections,
andfreedomfromcorrosion.
Periodiccleaningofmoduleglasshasresultedinimprovedperformancelevels,
especiallyinregionswithlowlevelsofannualprecipitation;thereforeMaxeon
recommendsperiodiccleaningofthe
modules.
Tocleanamodule,washitsglasssurfacewithpotable,non‐heatedwater.
NormalwaterpressureisadequatewhencleaningtheARglass.Some
fingerprints,stains,oraccumulationsofdirtontheglassmayberemovedwith
over‐the‐counterglasscleaners(suchasWindex
®
orequivalent),orwitha3%
soap‐and‐watersolution.Forsmallersystems,wetthemoduleglasswiththe
solution,letitstandforfiveminutes,andthenwetthemagainanduseasoft
spongeorseamlessclothtowipetheglasssurfaceinacircularmotion.Forlarge
systems,wetthemodules
withthecleaningsolution,letthemstandforfive
minutes,andthenrinsethemwithhigh‐pressurewaterorasoftsqueegee.Do
notuseharshindustrial‐strengthcleaningmaterialssuchasscouringpowder,
steelwool,scrapers,blades,orothersharpinstrumentstocleanthemodule
glass.Useofsuchmaterials
willvoidtheproductwarranty.

Recommended Cable Management


Portrait Stringing
Leapfrog Stringing (Portrait)
Maxeon Product Line:
Landscape Stringing

Maxeon MAX3 Specifications

General

Brand	Maxeon
Model	MAX3
Category	Control Unit
Language	English