Home
Mercury
Outboard Motor
200 Verado FourStroke
Mercury 200 Verado FourStroke User Manual
5
of 1
of 1 rating
144 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
eng
1
3
Table of Contents
Table of Contents
7
Warranty Registration United States and Canada
11
Transfer of Warranty United States and Canada
11
Warranty Information
11
Transfer of Mercury Product Protection (Extended Service Coverage) Plan United States and Canada
12
Year Limited Warranty against Corrosion
12
Warranty Coverage and Exclusions
14
U.S. EPA Emissions Limited Warranty
16
Emission Control System Components
16
California Emissions Limited Warranty
17
California Air Resources Board Explanation of Your California Emission Control Warranty Statement
19
Emission Certification Star Label
20
Warranty Policy-Australia and New Zealand
21
Global Warranty Charts Outboard and Jets
25
Boater's Responsibilities
30
Before Operating Your Outboard
30
Boat Horsepower Capacity
30
General Information
30
High-Speed and High-Performance Boat Operation
31
Outboard Remote Control Models
31
Lanyard Stop Switch
31
Protecting People in the Water
34
Exhaust Emissions
34
Passenger Safety Message - Pontoon Boats and Deck Boats
36
Wave and Wake Jumping
38
Impact with Underwater Hazards
39
Selecting Accessories for Your Outboard
40
Safe Boating Recommendations
40
Specifications
43
Recording Serial Number
45
Component Identification
45
350 HP Component Identification
46
Propeller Selection
46
Transporting
49
Trailering Boat/Outboard
49
Fuel Recommendations
51
Fuel Additives
52
Low Permeation Fuel Hose Requirement
52
Fuel and Oil
52
EPA Pressurized Portable Fuel Tank Requirements
53
Fuel Demand Valve (FDV) Requirement
53
Mercury Marine's Pressurized Portable Fuel Tank
53
Filling Fuel Tank
54
Engine Oil Recommendations
55
Checking and Adding Engine Oil
55
Panel Mount Control Features and Operation
58
Features and Controls
58
Slim Binnacle Control Features and Operation
60
Dual-Handle Console Control Features and Operation
66
Shadow Mode Control with CAN Trackpad Features and Operation
74
Warning System
77
Power Trim and Tilt
79
Important Daily Inspection before each Use
83
Prestarting Check List
83
Operation
83
Operating in Freezing Temperatures
84
Operating in Saltwater or Polluted Water
84
Operating at High Elevations
84
Propeller Selection
84
Effects of Elevation and Weather on Performance
85
Setting Trim Angle While Running Engine at Idle Speed
86
Engine Break-In Procedure
86
Fuel Supply Module Priming Procedure
86
Starting the Engine
88
Gear Shifting
91
Stopping the Engine
92
Outboard Care
93
EPA Emissions Regulations
93
Inspection and Maintenance Schedule
94
Flushing the Cooling System
96
Cowl Removal and Installation
97
Cleaning Care for Top and Bottom Cowls
99
Cleaning Care for the Powerhead (Saltwater Use)
99
Battery Inspection
99
Verado Engine Battery Specifications
100
Air Filter (200-300)
101
Air Filter (350, 350 Pro)
102
Fuel System
103
Corrosion Control Anodes
106
Corrosion Control Anodes (350 HP)
107
Trim Wear Pad Replacement
107
Propeller Replacement - 25.4 MM (1.0 In.) Diameter Propeller Shaft
108
Propeller Replacement - 31.75 MM (1-1/4 In.) Diameter Propeller Shaft
111
Spark Plug Inspection and Replacement
112
Fuses
115
DTS Wiring System
116
Accessory Drive Belt Inspection
117
Checking Power Trim Fluid
117
Checking Power Steering Fluid
119
Changing Engine Oil
119
Gearcase Lubrication
122
Storage Preparation
128
Protecting External Outboard Components
128
Storage
128
Protecting Internal Engine Components
129
Gearcase
129
Positioning Outboard for Storage
129
Battery Storage
129
Starter Motor will Not Crank the Engine
130
Engine will Not Start
130
Engine Starts but will Not Shift into Gear
130
Engine Runs Erratically
130
Troubleshooting
130
Performance Loss
131
Battery will Not Hold Charge
131
Local Repair Service
132
Service Away from Home
132
Parts and Accessories Inquiries
132
Service Assistance
132
Owner Service Assistance
132
Ordering Literature
135
Outboard Installation
137
Installation
137
Maintenance Log
144
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mercury 200 Verado FourStroke and is the answer not in the manual?
Ask a question
Mercury 200 Verado FourStroke Specifications
General
Brand
Mercury
Model
200 Verado FourStroke
Category
Outboard Motor
Language
English
Related product manuals
Mercury 200 VERADO
145 pages
Mercury 250 Verado FourStroke
144 pages
Mercury 150 Verado FourStroke
144 pages
Mercury 175 Verado FourStroke
144 pages
Mercury 400R Verado FourStroke
144 pages
Mercury V6 200
302 pages
Mercury 200
118 pages
Mercury 200 Optimax
122 pages
Mercury 200 OptiMax Jet Drive
391 pages
Mercury 250 VERADO
145 pages
Mercury 175 Verado
144 pages
Mercury 20
68 pages
Need help?
General
To Next Page