TROUBLESHOOTING
eng 123
• Spark plugs fouled or defective. Refer to Maintenance
section.
Engine Runs Erratically
POSSIBLE CAUSES
• Overheating ‑ Warning horn not working.
• Low oil pressure. Check oil level.
• Spark plugs fouled or defective. Refer to Maintenance
section.
• Incorrect setup and adjustments.
• Fuel is being restricted to the engine.
a. Engine fuel filter is obstructed. Refer to Maintenance
section.
b. Fuel tank filter obstructed.
c. Stuck anti‑siphon valve located on permanently built‑in
type fuel tanks.
d. Fuel line is kinked or pinched.
• Fuel pump failure.
• Ignition system component failure.
Performance Loss
POSSIBLE CAUSES
• Low oil pressure. Check oil level.
• Throttle not fully open.
• Damaged or improper size propeller.
• Incorrect engine timing, adjustments, or setup.
• Boat overloaded or load improperly distributed.
• Excessive water in bilge.
• Boat bottom is dirty or damaged.
Battery Will Not Hold Charge
POSSIBLE CAUSES
• Battery connections are loose or corroded.
• Low electrolyte level in battery.
To Next Page
Loading...
Need help?
General
