Mitsubishi S16R-Y1PTA - Chapter 9 LONG-TERM STORAGE; Chapter 11 TROUBLESHOOTING

CONTENTS-3
CONTENTS
Damper - Inspect.............................................. 8-3
Fuel system .........................................8-5
Fuel system - Inspect ....................................... 8-5
Fuel tank - Clean.............................................. 8-5
Fuel tank - Drain water..................................... 8-5
Fuel control link ball joint - Inspect ................... 8-6
Gauze filter - Clean .......................................... 8-6
Fuel filter - Replace .......................................... 8-7
Fuel pipe - Inspect............................................ 8-8
Lubricating system...............................8-9
Engine oil, Oil filter and Bypass oil filter -
Replace............................................................ 8-9
Engine oil for mixing of fuel and water -
Inspect ........................................................... 8-12
Oil pipe - Inspect ............................................ 8-12
Cooling system..................................8-13
Coolant - Change ........................................... 8-13
Radiator fins - Check and Clean .................... 8-15
Inlet and exhaust systems.................8-16
Turbocharger - Inspect................................... 8-16
Draining water from the exhaust muffler ........ 8-16
Air cleaner element - Clean, Check and
Replace.......................................................... 8-17
Electrical system................................8-18
Starter - Inspect.............................................. 8-19
Alternator - Inspect......................................... 8-19
Chapter 9
LONG-TERM STORAGE
Storing the engine in an inoperable
condition for 3 months or more............9-1
Preparation for storage .................................... 9-1
Maintenance during storage............................. 9-1
Using the engine after storage......................... 9-2
Storing the engine in an operable condition
for 3 months or more ...........................9-2
Operating the engine for maintenance............. 9-2
Chapter 10
TRANSPORTATION
Lifting the engine ...............................10-1
Chapter 11
TROUBLESHOOTING
General precautions.......................... 11-1
Contact a dealer of Mitsubishi Heavy Industries, Ltd.
for repair service ............................................ 11-1
Considerations before work ........................... 11-1
Cautions against contamination ..................... 11-1
Cautions regarding parts handling ................. 11-1
Work safety .................................................... 11-1
Troubleshooting ................................ 11-2
The starter does not crank or cranks slowly,
resulting in start failure ................................... 11-2
The starter cranks, but the engine does not
start ................................................................ 11-2
Output decrease............................................. 11-3
Exhaust smoke is white or blue...................... 11-4
Exhaust smoke is black or charcoal............... 11-5
Fuel consumption is high ............................... 11-6
Engine oil consumption is high....................... 11-7
Overheating.................................................... 11-7
Low engine oil pressure ................................. 11-8
When fuel has run out....................... 11-8
Chapter 12
MAIN SPECIFICATIONS
Main specifications............................ 12-1