Mitsubishi S16R-Y1PTA - Page 15

CONTENTS-4
CONTENTS
List of Illustrations
Fig. 1-1 Warning labels...................................... 1-9
Fig. 2-1 Engine front view.................................. 2-1
Fig. 2-2 Engine rear view................................... 2-1
Fig. 2-3 Engine left view .................................... 2-2
Fig. 2-4 Engine right view .................................. 2-2
Fig. 2-5 Manual stop lever ................................. 2-3
Fig. 2-6 Stop solenoid........................................ 2-3
Fig. 2-7 Revolution detection pickup ................. 2-3
Fig. 2-8 Oil filter alarm switch ............................ 2-4
Fig. 2-9 Air cleaner indicator.............................. 2-4
Fig. 2-10 Turning gear position
(while engine is running) ...................... 2-5
Fig. 2-11 Turning gear position
(when pushing shaft in) ........................ 2-5
Fig. 2-12 Turning gear position
(when turning shaft).............................. 2-5
Fig. 3-1 Priming pump - Handle......................... 3-2
Fig. 3-2 Fuel filter - Bleed air ............................. 3-2
Fig. 3-3 Fuel injection pump - Bleed air............. 3-2
Fig. 3-4 Priming pump tightening method.......... 3-3
Fig. 3-5 Priming pump head packing................. 3-3
Fig. 3-6 Oil filler and Oil level gauge.................. 3-4
Fig. 3-7 Pouring engine oil on valve mechanisms
and chamber ........................................ 3-4
Fig. 3-8 Coolant drain cock (Engine) ................. 3-5
Fig. 3-9 Coolant drain cock (Water pump)......... 3-5
Fig. 3-10 Radiator coolant level........................... 3-5
Fig. 3-11 Reserve tank coolant level ................... 3-5
Fig. 3-12 Battery electrolyte level - Inspect ......... 3-6
Fig. 3-13 Valves for open/closed position - Check3-7
Fig. 3-14 Fuel tank - Drain water ......................... 3-8
Fig. 3-15 Oil filler and Oil level gauge.................. 3-9
Fig. 3-16 Radiator filler cap ............................... 3-10
Fig. 3-17 Radiator coolant level......................... 3-10
Fig. 3-18 Reserve tank coolant level ................. 3-10
Fig. 3-19 Fuel control link - Check..................... 3-10
Fig. 3-20 Air cleaner - Check............................. 3-11
Fig. 3-21 Thermo label of damper ..................... 3-11
Fig. 3-22 Manual stop lever ............................... 3-14
Fig. 5-1 Recommended engine oil..................... 5-1
Fig. 5-2 Selection of oil viscosity ........................5-1
Fig. 6-1 GLASSY - LLC ......................................6-1
Fig. 8-1 Belt and belt tension - Inspect and Adjust8-
2
Fig. 8-2 Damper - Check visually .......................8-3
Fig. 8-3 Damper temperature management .......8-4
Fig. 8-4 Fuel tank - Drain water..........................8-5
Fig. 8-5 Ball joints for looseness - Inspect..........8-6
Fig. 8-6 Fuel control link - Remove.....................8-6
Fig. 8-7 Gauze filter - Clean ...............................8-6
Fig. 8-8 Fuel filter - Replace ...............................8-7
Fig. 8-9 Fuel filter ...............................................8-7
Fig. 8-10 High pressure fuel injection pipe and
Clamp seat - Inspect .............................8-8
Fig. 8-11 Low pressure fuel pipe and Clip -
Inspect...................................................8-8
Fig. 8-12 Oil filler and Oil level gauge ................8-10
Fig. 8-13 Oil filter and Bypass oil filter - Replace8-11
Fig. 8-14 Oil filter ................................................8-11
Fig. 8-15 Oil pipe and Clip - Inspect and Replace8-12
Fig. 8-16 Radiator filler cap ................................8-13
Fig. 8-17 Coolant drain cock (engine) ................8-13
Fig. 8-18 Coolant drain cock (water pump) ........8-14
Fig. 8-19 Radiator coolant level..........................8-14
Fig. 8-20 Reserve tank .......................................8-14
Fig. 8-21 Radiator fins - Clean ...........................8-15
Fig. 8-22 Turbocharger - Inspect........................8-16
Fig. 8-23 Draining water from the exhaust muffler8-16
Fig. 8-24 Air cleaner element - Remove.............8-17
Fig. 8-25 Air cleaner element - Clean and Check8-17
Fig. 8-26 Air cleaner - Check..............................8-17
Fig. 8-27 Battery electrolyte level - Inspect ........8-18
Fig. 8-28 Specific gravity of battery electrolyte -
Check ..................................................8-18
Fig. 8-29 Starter - Inspect...................................8-19
Fig. 8-30 Alternator - Inspect..............................8-19
Fig. 10-1 Hangers...............................................10-1
Fig. 10-2 Engine's center of gravity
(standard specification) .......................10-1