TABLE OF CONTENTS
1.0 INTRODUCTION ................................................................................................................ 3
2.0 INTRODUCTION ................................................................................................................ 6
3.0 BOILER LOCATION .......................................................................................................... 7
4.0 GENERAL VENTING ......................................................................................................... 8
5.0 VENT AND AIR-INTAKE TERMINATION CLEARANCES ........................................ 17
6.0 CONDENSATE DRAIN .................................................................................................... 20
7.0 INSTALLING GAS PIPING .............................................................................................. 21
8.0 LIGHTING THE BOILER ................................................................................................. 23
9.0 GAS VALVE AND BURNER SET-UP ............................................................................ 25
10.0 BOILER AND HEATING SYSTEM PIPING ................................................................... 28
11.0 DOMESTIC HOT WATER PLUMBING AND OPERATION ........................................ 35
12.0 FIELD WIRING ................................................................................................................. 39
13.0 CONTROL SETUP ............................................................................................................ 43
14.0 MATRIX BLOWER OPERATION ................................................................................... 48
15.0 HEAT RECOVERY VENTILATION ............................................................................... 50
16.0 WIRING SCHEMATICS ................................................................................................... 55
17.0 INSTALLATION CHECKLIST ........................................................................................ 57
18.0 ANNUAL MAINTENANCE AND INSPECTION ........................................................... 58
19.0 PARTS LIST ....................................................................................................................... 60
20.0 TROUBLESHOOTING ....................................................................................................... 66
HAZARD SYMBOLS AND DEFINITIONS
Danger Sign: Indicates a hazardous situation which, if not avoided, will
result in serious injury or death.
Warning Sign: Indicates a hazardous situation which, if not avoided,
could result in serious injury or death.
Caution Sign plus Safety Alert Symbol: Indicates a hazardous situation
which, if not avoided, could result in minor or moderate injury.
Caution Sign without Safety Alert Symbol: Indicates a hazardous
situation which, if not avoided, could result in property damage.
Notice Sign: Indicates a hazardous situation which, if not avoided,
could result in property damage.
This Boiler must be installed by a licensed and trained Heating
Technician or the Warranty is Void. Failure to properly install this
unit may result in property damage, serious injury to occupants, or
possibly death.
To Next Page
Need help?
General
