Nussbaum 4.50H - Default Chapter; Table of Contents

Table of contents
F OREWORD ........................................................................................................................................................... 3
R ECORD OF INSTALLATION ....................................................................................................................................... 5
R ECORD OF HANDING OVER ..................................................................................................................................... 6
1 INTRODUCTION ............................................................................................................................................. 7
1.1 I NSTALLATION AND CHECK OF THE AUTOMOTIVE LIFT ....................................................................................... 7
1.2 W ARNING NOTICES ..................................................................................................................................... 7
2 MASTER DOCUMENT OF THE AUTOMOTIVE LIFT ..................................................................................... 8
2.1 L IFT - MANUFACTURER .................................................................................................................................. 8
2.2 A PPLICATION .............................................................................................................................................. 8
2.3 C HANGES TO THE CONSTRUCTION ................................................................................................................ 8
2.4 D ISPLACEMENT OF THE AUTOMOTIVE - LIFT ..................................................................................................... 8
2.5 D ECLARATION OF CONFORMITY .................................................................................................................... 9
3 TECHNICAL INFORMATION ........................................................................................................................ 10
3.1 T ECHNICAL RATINGS ................................................................................................................................. 10
3.3 D ATASHEET ............................................................................................................................................. 11
3.4 F OUNDATION DIAGRAM .............................................................................................................................. 13
3.5 H YDRAULIC DIAGRAM W / O WHEEL FREE JACK ............................................................................................... 14
3.6 H YDRAULIC DIAGRAM WITH WHEEL FREE JACK .............................................................................................. 15
3.7 E LECTRICAL DIAGRAM W / O WHEEL FREE JACK .............................................................................................. 17
3.8 E LECTRICAL DIAGRAM WITH WHEEL FREE JACK ............................................................................................. 19
3.9 C ONNECTION - COMMAND ( PICTURE ) ............................................................................................................ 21
4 SAFETY REGULATIONS .............................................................................................................................. 26
5 OPERATING INSTRUCTIONS ...................................................................................................................... 26
5.1 L IFTING THE VEHICLE WITH AUTOMOTIVE LIFT ............................................................................................... 26
5.2 L OWERING THE VEHICLE WITH AUTOMOTIVE LIFT .......................................................................................... 27
5.3 L OWERING THE AUTOMOTIVE LIFT IN THE RATCHET STRIP ( WHEEL ALIGNMENT ) ................................................ 27
5.4 R AISE THE AUTOMOTIVE LIFT OUT OF THE RATCHET STRIP ............................................................................. 27
5.5 L IFTING THE VEHICLE WITH WHEEL FREE JACK .............................................................................................. 27
5.6 L OWERING THE VEHICLE WITH WHEEL FREE JACK ......................................................................................... 28
5.7 E QUALIZATION OF DRIVE ON RAILS .............................................................................................................. 28
6 TROUBLESHOOTING .................................................................................................................................. 28
6.1 D RIVING ON AN OBSTACLE WITH THE MAIN LIFT ............................................................................................. 29
6.2 E MERGENCY LOWERING IN CASE OF POWER FAILURE OR DEFECTIVE VALVE ..................................................... 29
6.3 E MERGENCY LOWERING OF THE WHEEL FREE LIFT ........................................................................................ 30
7 INSPECTION AND MAINTENANCE ............................................................................................................. 31
7.1 M AINTENANCE PLAN OF THE LIFT ................................................................................................................ 31
7.2 H OW OFTEN MUST THE LIFT BE CLEANED ? ................................................................................................... 32
8 SECURITY CHECK ............................................................................................................................................ 33
9 INSTALLATION AND INITIATION ................................................................................................................. 33
9.1 R EGULATIONS .......................................................................................................................................... 33
9.2 E RECTING AND DOWELLING THE LIFT ........................................................................................................... 34
9.3 A DJUSTING THE RAILS ............................................................................................................................... 36
9.4 I NITIATION ................................................................................................................................................ 36
9.5 D ISPLACEMENT OF THE AUTOMOTIVE LIFT .................................................................................................... 37
9.6 C ONNECTING THE OPERATING UNIT ............................................................................................................. 37
9.7 P OSITION OF THE COLUMNS ....................................................................................................................... 38
C HOICE OF THE DOWEL LENGTH W / O FLOOR PAVEMENT OR TILE SURFACE ................................................................... 39
F IRST SECURITY CHECK BEFORE INSTALLATION ........................................................................................................ 41
R EGULAR SECURITY CHECK ................................................................................................................................... 42
E XTRAORDINARY SECURITY CHECK ......................................................................................................................... 47