Panther 55 - Troubleshooting; Unit Does Not Run; Unit Runs in One Direction; Noise and Low Power

TROUBLESHOOTING
Thefollowingaresomeprocedurestofollowbeforecallinginforserviceorwarrantywork:
UNIT DOES NOT RUN 
1.CheckBaery&Connecons.
2.CheckElectricMotor.
Useadoubleleadjumperandconnectthemotor’stwo
prongplugdirectlytoabaery.
3.Ifthemotorslldoesnotwork,disconnectthemotorfromthe
actuator(heldonbytwosmallnuts)andplugdirectlytothe
baery.
4.Ifthemotorworkswhenitisdisconnectedfromtheactuator,the
actuator/motorassemblyneedsreplaced.
5.Ifthemotordoesnotworkwhendisconnectedfromtheactuator,
themotorneedsreplaced.
6.CheckRelayControl&PushBuonSwitch.
Unplugthethreeprongconnectorattherelaycontrol
andrunajumperwirebetweentheredandthegreenwiresto
godownandbetweentheredandbluewirestogoup.
IftheunitdoesnotruntheproblemistheRelayControl.
IfitdoesworkthentheproblemisthePushBuonSwitch.

UNIT RUNS IN ONE DIRECTION ONLY
CheckRelayControl&PushBuonSwitch
Unplugthethreeprongconnectorattherelaycontrol
andrunajumperwirebetweentheRedandtheGreenwiresto
godownandbetweentheRedandBluewirestogoup.
IftheunitdoesnotruntheproblemistheRelayControl.
IfitdoesworkthentheproblemisthePushBuonSwitch.

UNIT RUNS BUT MAKES A GRINDING NOISE AND HAS LOW POWER
Gearcaselowongrease.Addacoupleofpumpsof
marinegradegrease.
UNIT RUNS BUT DOES NOT MOVE
ReplaceActuator.
UNIT RUNS BUT MAKES CLICKING NOISE OR JUMPS
Replaceactuator.
UNIT STARTS AND RUNS ON ITS OWN
Replacerelaycontrol.
DETERMINE IF WATER IS IN ELECTRIC MOTOR
Removethroughboltthatisclosesttothewiresandlookforan
indicaonofrustonthebolt.Rustindicateswaterinsideofthemotor
housing.Motorandactuatorshouldbereplaced.