Pentair MT Sizes 500 - Default Chapter; Table of Contents; Pentair Technical Support

Pentair Water Commercial Pool and Spa
Page 2
TABLE OF CONTENTS
SECTION 1.
General Information
1.1 Introduction................................................... 3
1.2 Heater Identification ..................................... 3
1.3 Primary/Secondary Pump and Piping........... 3
1.4 Certifications................................................. 3
1.5 Engineering Assistance ................................ 3
SECTION 2.
Installation
2.1 Boiler Placement .......................................... 4
2.2 Installation of Indoor Boilers ......................... 4
2.2.1 Combustion Air Supply ................................. 4
2.2.2 Venting ......................................................... 5
2.2.3 Common Venting System
Test Procedure ............................................. 6
2.2.3 Instructions Relatives au Test des
Systèmes à Évent Commun ......................... 6
2.3 Installation of Outdoor Boilers ...................... 7
2.4 Gas Supply and Piping ................................. 7
2.5 Electrical Wiring............................................ 8
2.6 General Piping Instructions .......................... 9
2.7 Boiler By-Pass Piping ................................... 9
2.8 Temperature Sensor Placement
and Installation ............................................ 10
2.9 Automatic Chlorinators ............................... 10
SECTION 3.
Operation
3.1 Controls - General ...................................... 11
3.2 Initial Start-Up ............................................. 11
3.3 Safety Shutoff Component Checkout ......... 12
3.4 Inlet Temperature and
Temperature Rise Adjustment .................... 12
3.5 Heater Shut Down ...................................... 13
3.6 Spring and Fall Operation
Stand-by Service ........................................ 13
3.7 Winter Operation Complete Shutdown ....... 14
3.8 Time Clock Operation................................. 14
3.9 Therapeutic Pools (Spas) ........................... 14
SECTION 4.
Maintenance..............................................15
SECTION 5.
Troubleshooting .......................................16
SECTION 6.
Parts Description and Order Numbers ................ 17
Pentair Technical Support
Sanford, North Carolina (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (919) 566-8920
Moorpark, California (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (800) 284-4151
Web sites: visit www.pentairpool.com and www.staritepool.com