Perkins 403D-07 - Page 96

Fire Prevention and Explosion Prevention.......11
Ether ............................................................ 12
Fire Extinguisher.......................................... 12
Lines, Tubes, and Hoses ............................. 12
Fluid Recommendations ................................. 54
Engine Oil .................................................... 54
General Lubricant Information..................... 54
Fluid Recommendations (Coolant
Specifications) ............................................... 50
ELC Cooling System Maintenance.............. 52
General Coolant Information ....................... 50
Fluid Recommendations (Fuel
Specification) ................................................. 43
Diesel Fuel Characteristics.......................... 45
Diesel Fuel Requirements ........................... 44
General Information..................................... 43
Foreword ........................................................... 4
California Proposition 65 Warning ................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 39
Fuel Conservation Practices ........................... 35
Fuel Injector - Test/Change ............................. 78
Identification of a suspect Fuel Injector ....... 79
Fuel Related Components in Cold Weather ... 40
Fuel Filters ................................................... 40
Fuel Heaters ................................................ 40
Fuel Tanks ................................................... 40
Fuel Shutoff ..................................................... 31
Fuel System - Prime ........................................ 79
Fuel filters .................................................... 80
Primary filter................................................. 79
Priming the system ...................................... 81
Fuel System Filter - Replace........................... 84
Fuel Filter with Canister............................... 84
Fuel Filter with Element ............................... 85
Fuel Filter with Priming Pump...................... 85
In Line Fuel Filter ......................................... 86
Fuel System Primary Filter - Replace ............. 87
Install the Element ....................................... 88
Remove the Element ................................... 87
Fuel System Primary Filter/Water
Separator - Drain ........................................... 88
Fuel Tank Water and Sediment - Drain ........... 89
Drain the Water and the Sediment .............. 89
Fuel Storage Tanks...................................... 89
Fuel Tank ..................................................... 89
G
Gauges and Indicators .................................... 30
General Hazard Information.............................. 8
Containing Fluid Spillage............................... 9
Fluid Penetration ........................................... 9
Inhalation ....................................................... 9
Pressure Air and Water ................................. 8
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ......................... 9
H
Hoses and Clamps - Inspect/Replace............. 89
Replace the Hoses and the Clamps ............ 90
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 27
M
Maintenance Interval Schedule....................... 60
Daily ............................................................. 60
Every 1000 Service Hours........................... 60
Every 2000 Service Hours........................... 60
Every 250 Service Hours or 6 Months......... 60
Every 3000 Service Hours........................... 60
Every 3000 Service Hours or 2 Years ......... 60
Every 4000 Service Hours........................... 60
Every 50 Service Hours or Weekly.............. 60
Every 500 Service Hours or 1 Year ............. 60
Every 6000 Service Hours or 3 Years ......... 60
When Required............................................ 60
Maintenance Recommendations .................... 58
Maintenance Section....................................... 41
Model View Illustrations .................................. 15
Engines with Factory Installed Radiators .... 19
Model Views .................................................... 15
O
Operation Section............................................ 27
P
Product Identification Information ................... 25
Product Information Section............................ 15
96
SEBU8311-09
Index Section