Name: PIAGGIO X9 500 cc
Brand: PIAGGIO
Rating: 4 (1 reviews)

To Next Page

To Previous Page

TABLE OF CONTENTS

ELECTRICAL EQUIPMENT

Table of Contents3
Assembly Plays4
Mating between Piston and Cylinder4
Piston Rings4
Shimming Method for Limiting the Compression Ratio: CR = 10.5:15
Crankshaft/Crankcase Axial Clearance 0.1 - 0.5 MM (Cold Engine)5
Crankshaft/Connecting Rod Axial Clearance6
Crankshaft Alignmeht and Diameters6
Specific Tooling7
Recommended Tools Table8
Necessary Tools Table9
Spark Plug Check and Replacement10
Air Filter10
Maintenance11
Engine Oil Level11
Checking/Topping up the Oil Level11
Oil Pressure Warning Light/Renewing the Oil and the Filter11
Replacing the Filter12
Checking the Hub Oil Level12
Renewing the Hub Oil12
Engine Cooling13
Adding Coolant and Bleeding Air from the System13
Water Pump13
Adjusting the Play of the Valves - Checking the Valve Gear Timing14
Checking/Restoring the Brake Fluid Level14
Steering Lock Disassembly with Lock Turned to "OFF"15
Steering Lock Removal with Lock in LOCK Position16
Adjusting the Headlight16
Electrical Equipment17
Electrical Equipment Diagram and Parts List18
Electrical Equipment Devices List19
Electrical Cables Colour19
Schematic Wiring Diagrams20
Ignition Switch Wiring Diagram20
Light Section Wiring Diagram21
Battery Recharge and Starter Section Wiring Diagram22
Consent, Electrohydraulic Central Stand Device and Level Indicators Section Wiring Diagram23
Turn Indicators, Horn and Accessories Prewiring Section Wiring Diagram24
Control Panel, Warning Lights, Instruments Wiring Diagram25
Battery Recharge System26
Recharging System26
Searching for Leaks26
Checking the Charging Voltage26
Checking the Stator Winding27
Checking the Peak Current27
Voltage Regulator/Rectifier - Specifications27
Instrument Panel28
List of Bulbs29
Battery (12V - 14Ah)30
Installing Charged-Dry Batteries30
Removing and Installing the Battery30
Checking the Electrolyte Level/Battery Charge33
Battery Recharge/Cleaning33
Sealed Battery/Recharging the Battery Following Open-Circuit Storage33
Engine34
Engine Disassembly from Frame35
Muffler Assembly Disassembly35
Supporting Arm Disassembly36
Disassembly of I.h. Shock Absorber Lower Pin36
Engine Pin/Swing Arm Disassembly36
Engine Assembly to Vehicle36
Handlebar Removal/Fitting37
Removing/Overhauling the Front Wheel37
Front and Rear Suspensions38
Removing the Front Fork39
Replacing the Steering Bearings39
Fitting the Steering Bearing40
Replacing the Seal Ring and Removing the Fork Rod41
Rear Shock Absorbers Removal/Fitting41
Rear Wheel Removal/Fitting42
Central Stand Removal/Fitting42
Braking System43
Braking System Diagram44
Checking and Replacing the Brake Pads45
Removing the Front Brake Pads45
Removing and Replacing the Rear Brake Pads45
Brake Discs46
Checking Disc Thickness/Distortion46
Replacing the Front/Rear Brake Discs46
General Guidelines for Servicing the Hydraulic Braking System47
Renewing the Brake Fluid and Bleeding Air from the Brake Circuit47
Combined Brake48
Removing the Brake Calipers/Brake Pumps49
Replacing the Pressure Divider Valve50
Bodywork51
Front Central Cover53
Lower Guard - Windscreen53
Front Lamp Cluster53
Front Shield53
Digital Instrument Panel Support54
Front/Rear Handlebar Cover54
Table of Working Times55
Engine Working Times56
Crankcase Working Times56
Crankshaft Working Times56
Cylinder - Piston - Piston Pin Assembly Working Times56
Cylinder Head Working Times57
Rocker Arm Support Assembly Working Times57
Cylinder Head Cover Working Times57
Flywheel Cover Working Times57
Driven Pulley and Clutch Working Times58
Oil Pump Working Times58
Reduction Gearing Assembly Working Times58
Driving Pulley Working Times58
Transmission Cover Working Times59
Starter Motor Working Times59
Flywheel Magneto Working Times59
Throttle Body Working Times59
Air Cleaner Working Times60
Silencer Working Times60
Tank Working Times60
Frame Body Working Times60
Swingarm Working Times61
Central Stand/Electrohydraulic Working Time61
Side Stand Working Times61
Front Shield Working Times61
Windscreen Working Times62
Rear Shield Working Times62
Footboard - Fuel Tank Door Working Times62
Expansion Tank Working Times62
Radiator Working Times63
Undersaddle Compartment Working Times63
Mats and Covers Working Times63
Front Mudguards Working Times63
Saddle Working Times64
Steering Thrust Rings Working Times64
Front Fork Working Times64
Rear Shock Absorber Working Times64
Instrument Panel Working Times65
Handlebar Covers/Components Working Times65
Brake Lines Working Times65
Brake Caliper Working Times66
Headlight Working Times66
Rear Light Working Times66
Rear Covers Working Times66
Electrical Devices Working Times67
Battery and HV Coil Working Times67
Fuel Injection Control Unit Working Times67
Voltage Regulator Assembly Working Times67
Radio - Intercom Working Times68
Wiring (Wiring Harness) Working Times68
Locks Working Times68
Front Wheel Working Times68
Rear Wheel Working Times69

Brand	PIAGGIO
Model	X9 500 cc
Category	Scooter
Language	English

PIAGGIO X9 500 cc User Manual

Table of Contents

Questions and Answers:

PIAGGIO X9 500 cc Specifications

Related product manuals