2.4
MAINTENANCE
Periodic Maintenance Chart
Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
Have an authorized Polaris dealer perform these services.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(KM)
Steering - Pre-Ride -
Make adjustments as needed.
Front-suspension - Pre-Ride -
Rear-suspension - Pre-Ride -
Tires - Pre-Ride -
Brake fluid level - Pre-Ride -
Brake lever travel - Pre-Ride -
Brake systems - Pre-Ride -
Wheels /fasteners - Pre-Ride -
Frame fasteners - Pre-Ride -
E
Engine oil level - Pre-Ride -
Passenger Seat Lock Out - Pre-Ride - Verify Seat is secured
Dump Box Operation - Pre-Ride - Verify Box is latched
E
Air filter, pre-filter - Daily - Inspect; clean often
E
Air box sediment tube - Daily - Drain deposits when visible
Coolant - Daily -
Check level daily, change coolant every 2
years
Headlamp/tail lamp - Daily -
Check operation; apply dielectric grease if
replacing
E
Air filter,
main element
- Weekly - Inspect; replace as needed
Recoil housing - Weekly -
Drain water as needed, check often if
operating in wet conditions
Brake pad wear 10 H Monthly 60 (100) Inspect periodically
Battery 20 H Monthly 125 (200) Check terminals; clean; test
Front gearcase oil (if
equipped)
25 H Monthly 155 (250) Inspect level; change yearly
Middle gearcase oil (if
equipped)
25 H Monthly 155 (250) Inspect level; change yearly
Rear gearcase oil
(if equipped)
25 H Monthly 155 (250) Inspect level; change yearly
Transmission oil 25 H Monthly 155 (250) Inspect level; change yearly
To Next Page
Loading...
