Polaris Sportsman 500 X2 2007 User Manual (English)

Questions and Answers:

B
Barbara ArmstrongAug 13, 2025
What to do if my Polaris Sportsman 500 X2 2007 engine runs irregularly, stalls, or misfires?
- J
  Jose RodriguezAug 13, 2025
  If your Polaris Offroad Vehicle's engine runs irregularly, stalls, or misfires, here's what you can check: * Inspect, clean, or replace fouled or defective spark plugs. * Check and tighten loose ignition connections. * Replace fuel if water is present. * Recharge the battery if the voltage is low. * Inspect and replace a kinked or plugged fuel tank vent line. * Replace with recommended fuel if the fuel is incorrect, low octane, or very high octane. * Inspect, clean, or replace a clogged air filter. * Replace the filter if the fuel filter is clogged. Also, allow the engine to warm up before operating and/or stopping.
D
Derek SnyderAug 17, 2025
What to do if my Polaris Offroad Vehicle engine stops or loses power?
- B
  brownhaydenAug 17, 2025
  If your Polaris Offroad Vehicle engine stops or loses power, consider the following: * Refuel, cycling the key to the ON position three times for 5 seconds each, then start. * Inspect and replace a kinked or plugged fuel vent line (if equipped). * Replace fuel if water is present, or if the fuel is old or non-recommended. * Inspect, clean, or replace fouled or defective spark plugs. * Set the gap to specifications or replace the spark plug if the gap or heat range is incorrect. * Check and tighten loose ignition connections. * Recharge the battery if the voltage is low. * Inspect and clean or replace a clogged air filter.
T
Thomas BonillaAug 21, 2025
What to do if my Polaris Sportsman 500 X2 2007 engine rotates but fails to start?
- A
  Alyssa GreenAug 21, 2025
  If your Polaris Offroad Vehicle engine rotates but fails to start, check these: * Refuel if out of fuel. * Replace the filter if the fuel filter is clogged. * Drain and refuel the fuel system if water is present in the fuel. * Replace with fresh recommended fuel if the fuel is old or non-recommended. * Inspect and replace spark plugs if they are fouled or defective. * Inspect plugs and verify the stop switch is on if there is no spark to the spark plug. * Recharge the battery to 12.8 VDC if the battery voltage is low.
A
Anthony MyersAug 28, 2025
What causes a Polaris Sportsman 500 X2 2007 engine to overheat?
- J
  Jasmine HornAug 28, 2025
  Your Polaris Offroad Vehicle engine may overheat if: * Debris is lodged in the screen: Remove and clean the screen. Pull on the top portion of the screen, then remove the lower portion. * The radiator is plugged: Use a garden hose to flush any debris from the radiator fins. Note: High pressure washers can deform the radiator fins and reduce cooling efficiency.
A
Angela BeckerSep 1, 2025
Why won't my Polaris Sportsman 500 X2 2007 Offroad Vehicle engine rotate?
- D
  Dylan EstradaSep 1, 2025
  If your Polaris Offroad Vehicle engine won't rotate, check for: * Low battery voltage: Recharge the battery to 12.8 VDC. * Loose battery connections: Check all connections and tighten. * Loose solenoid connections: Check all connections and tighten.
L
Lisa HendrixSep 4, 2025
What causes a Polaris Sportsman 500 X2 2007 Offroad Vehicle engine to backfire?
- L
  lgrantSep 4, 2025
  A Polaris Offroad Vehicle engine may backfire due to: * Weak spark from the spark plug: Inspect, clean, and/or replace spark plug(s). * Incorrect spark plug gap or heat range: Set the gap to specifications or replace the plugs. * Loose ignition connections: Check all connections and tighten. * Water present in fuel: Replace with fresh recommended fuel.
M
Mark RiveraSep 8, 2025
Why does my Polaris Sportsman 500 X2 2007 Offroad Vehicle engine ping or knock?
- L
  lewisscottSep 8, 2025
  Your Polaris Offroad Vehicle engine might ping or knock due to: * Poor quality or low octane fuel: Replace with recommended fuel. * Incorrect spark plug gap or heat range: Set gap to specs or replace plugs.