Polaris 800 RMK User Manual

87
MAINTENANCE
Intake Filters
The intake foam filters
limit snow ingestion into
the intake system. When
operating in loose powder
snow, check the foam
filters periodically to
remove any accumulation
of snow.
Fuel Pump
All fuel pump service must be performed by an authorized POLARIS
dealer. Do not attempt to service the fuel pump.
Fuel Filter/Fuel Lines
See your POLARIS dealer for replacement of the fuel filter at the
intervals outlined in the Periodic Maintenance Table beginning on page
80.
Contaminated or poor quality fuel will shorten the life of the fuel filter
and result in poor engine performance. Always store fuel in clean fuel
containers. If low fuel pressure or reduced engine performance occurs
between the recommended fuel filter service intervals, the filter may
need replacement. See your dealer.
Inspect the fuel lines regularly for signs of deterioration or damage.
Always check fuel line condition after periods of storage. Normal
deterioration from weather and fuel compounds may occur. Replace
worn or damaged fuel lines promptly.
NOTICE: Kinking the fuel lines or using a pliers or similar tools to remove fuel
lines may cause damage to the lines. If a fuel line has been damaged
or kinked, replace it promptly.
Intake
Filters

Polaris 800 RMK Specifications

General

Bore x Stroke	85 mm x 70 mm
Engine Stroke	2-Stroke
Rear Suspension	RMK Adjustable
Track Width	15 inches
Track Length	155 in (393.7 cm) / 163 in (414 cm)
Track Height	2.4 inches
Fuel Capacity	11.5 gallons
Engine	Liberty 800
Rear Travel	16 in (40.6 cm)
Displacement	794cc