Polaris RANGER 150 EFI 2020

ITEM REMARKS
XU
Spark Plug Inspect; replace as needed
XU
Engine Mounts Inspect
Exhaust Muffler / Pipe Inspect
XU
Wiring
Inspect for wear, routing, security; apply dielectric grease
to connectors subjected to water, mud, etc.
XU
Clutches (Drive and Driven) Inspect; clean; replace worn parts
Drive belt
Inspect; replace as needed
D
Front wheel bearings Inspect; replace as needed
D Brake fluid
Change every two years
225 HOUR / 2250 MILE (3600 KM) SERVICE
ITEM REMARKS
Fuel System
Inspect; cycle key to pressurize fuel pump; check lines and
fittings for leaks and abrasion
Battery
Check terminals; clean; test
XU Main Gearcase Oil
Inspect level; change yearly
XU
Engine Oil Change
250 HOUR / 2500 MILE (4000 KM) SERVICE
ITEM REMARKS
XU
Fuel System
Inspect; cycle key to pressurize fuel pump; check lines and
fittings for leaks and abrasion
Battery
Check terminals; clean; test
XU Main Gearcase Oil
Inspect level; change yearly
XU
Engine Oil Change
D Valve Clearance
Valve lash adjustment
XU General Lubrication
Lubricate all fittings, pivots, cables, etc.
Shift Linkage Inspect, lubricate, adjust
D
Steering
Lubricate
XU
Front Suspension
Lubricate
XU
Rear Suspension
Lubricate
Throttle Body Intake Duct Inspect duct for proper sealing/air leaks
LUBRICATION RECOMMENDATIONS
Check and lubricate all components at the intervals outlined in the Periodic
Maintenance Chart beginning on page 68, or more often under severe use, such
as wet or dusty conditions. Items not listed in the chart should be lubricated at
the general lubrication interval.
72
MAINTENANCE