ENGINE DOESN’T TURN OVER
POSSIBLE CAUSE SOLUTION
Low battery voltage Recharge the battery to 12.8 VDC
Loose battery connections Check all connections and tighten
Loose solenoid connections Check all connections and tighten
Loose electronic control box
connections
Inspect, clean, reinstall connectors;
blow on EFI fuse to remove impurities
Mechanical failure Your POLARIS dealer or other
qualified person can assist.
ENGINE TURNS OVER, FAILS TO START
WARNING
Never pour fuel or other flammable liquid into the throttle body air inlet opening
in an attempt to start the vehicle. This could result in a flash fire causing
serious injury or death.
POSSIBLE CAUSE SOLUTION
Out of fuel Refuel
Clogged fuel filter Your POLARIS dealer or other
qualified person can assist.
Water is present in fuel Drain the fuel system and refuel
Old or non-recommended fuel Replace with fresh recommended
fuel
Fouled or defective spark plugs Inspect plugs and replace if
necessary
No spark to spark plug Inspect plugs and replace if
necessary
Water or fuel in crankcase Your POLARIS dealer or other
qualified person can assist.
Low battery voltage Recharge the battery to 12.8 VDC
Loose ignition connections Check all connections and tighten
155
TROUBLESHOOTING
To Next Page
Loading...
Need help?
General
