POLARIS MAINTENANCE SCHEDULE
The intervals shown are based on vehicles operated under normal conditions.
Each interval is given in hours and miles (kilometers). Items should be serviced
at whichever interval comes first following the Initial Break-In Service.
Continue to reference the following maintenance schedules at the given
intervals as hours and miles (kilometers) increase on the vehicle.
Vehicles subjected to severe use must be serviced at 50% of the stated interval.
Examples of Severe Use: Frequent immersion in mud, water, or sand, constant
high RPM use, prolonged low-speed heavy load operation, extended idle, short
trip cold weather operation, and prolonged high speed operation.
INITIAL BREAK-IN SERVICE
FIRST 25 HOURS / 1 MONTH
Engine Oil and Filter Change the engine oil and filter.
Engine Air Filter
Inspect air filter; replace as necessary. Ensure
proper installation of filter and airbox cover.
Inspect ducts and screens; clean and replace
as necessary.
Brake System Initial inspection; replace as necessary.
General Lubrication
Inspect, lubricate, and adjust as necessary.
Tires
Initial inspection; replace as necessary.
Battery
Test battery condition and charge level. Check
terminals; terminals should be tight and free of
corrosion. Clean, test, and replace as
necessary.
Front Gearcase Fluid
Change fluid.
Transmission Fluid
Initial fluid level inspection; adjust fluid level as
necessary.
Parking Brake (if
applicable)*
Inspect; adjust as needed.
Drive Belt
Inspect, clean, and replace as necessary.
Clutches
Inspect weights, bushings, rollers, wearable
parts; clean; replace worn parts as needed.
Spark Arrestor Inspect; clean as needed.
104
MAINTENANCE
To Next Page
Loading...
