84
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
More often under severe use, such as dirty or wet conditions to
purge water or dirt contamination from grease fittings and other
critical components.
Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty.
Item Hours or
Miles
When Remarks
Transmission Oil
Level
20 hrs Monthly Inspect monthly; change
annually
Battery 20 hrs Monthly Check Terminals/clean/
check fluid level
Engine breather filter
(4-cycle)
20 hrs Monthly Inspect-replace annually
and as needed
Brake pad wear 20 hrs Monthly Inspect periodically
Front and Rear Gear-
case Oil (shaft drive)
100 hrs Monthly Check monthly and
change annually
General Lubrication 50 hrs 3
months
Lubricate all fittings, pivots,
cables, etc.
Engine Oil - Level/
Change (4-Cycle)
100 hrs /
1000
miles
6
months
Check Level Daily; Break
in Service at 1 month.
Change oil more often in
cold weather use.
Due to the nature of the adjustments marked with a on the
following chart, it is recommended that service be performed by
an authorized Polaris dealer.
CAUTION
To Next Page
Loading...
Need help?
General
