86
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
More often under severe use, such as dirty or wet conditions to
purge water or dirt contamination from grease fittings and other
critical components.
Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty.
Item Hours or
Miles
When Remarks
Ignition Timing 100 hrs 12
months
Inspect and adjust as
needed
Fuel System 100
hours
12
months
Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor. Re-
place lines every two
years.
Fuel Filter 100 hrs 12
months
Replace annually
Radiator 100 hrs 12
months
Inspect/clean external sur-
face
Cooling System
hoses
100 hrs 12
months
Inspect
Spark arrestor 100 hrs 12
months
Clean out
Clutches (drive and
driven)
100 hrs 12
months
Inspect, clean
Due to the nature of the adjustments marked with a on the
following chart, it is recommended that service be performed by
an authorized Polaris dealer.
CAUTION
To Next Page
Loading...
Need help?
General
