59
MAINTENANCE
Periodic Maintenance Chart
Perform all services at whichever maintenance interval is reached first.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
Steering -
Pre-Ride
-
Make adjustments as need
ed. See Pre-Ride Checklist
on page 40.
Front suspension - -
Rear suspension - -
Tires - -
Brake fluid level - -
Brake lever travel - -
Brake system - -
Drive chain - -
Wheels/fasteners - -
Frame fasteners - -
Engine oil level - -
E
Air filter, pre-filter - Daily - Inspect; clean often; replace
as needed
Air box sediment
tube
- Daily - Drain deposits when visible
Headlamp/tail
lamp
- Daily - Check operation; apply
dielectric grease if replacing
E
Air filter, main
element
- Weekly - Inspect; replace as needed
Recoil housing (if
applicable)
- Weekly - Drain water as needed,
check often if operating in wet
conditions
D
Brake pad wear 10 H Monthly 100 (160) Inspect periodically
Battery 20 H Monthly 200 (320) Check terminals; clean; test
E
Engine breather
filter (if equipped)
25 H Monthly 250 (400) Inspect; clean if needed
Engine oil change 25 H 1 M 250 (400) Break-in oil and filter change
Transmission oil 25 H 1 M 250 (400) Break-in oil level check
General lubrication 50 H 3 M 500 (800) Lubricate all fittings, pivots,
cables, etc.
Carburetor float
bowl
50 H 6 M 500 (800) Drain bowl periodically and
prior to storage
D
E
Throttle Cable/
Throttle Release
Switch
50 H 6 M 500 (800) Inspect; adjust; lubricate;
replace if necessary
D
E
Choke cable 50 H 6 M 500 (800) Inspect; adjust; lubricate;
replace if necessary
To Next Page
Loading...
Need help?
General
