24
RESUMPTION OF SERVICE
1. Remove the covering and clean the vehicle. Change the lubricating oil if the vehicle has
been off service for more than 4 months.
2. Drain off the anti-rust solution from the fuel tank, followed by filling fuel therein to the
required level.
3. Prior to driving, test the vehicle at a low speed in a safe place.
MAINTENANCE ROUTINE DIAGRAM
The vehicle should be under good maintenance as specified in the following table, where:
“I” means: Check, cleaning, adjustment, lubrication and/or replacement are needed.
“C” means: Cleaning is needed.
“R” means: Replacement is needed.
“A” means: Adjustment is needed.
“L” means: Lubrication is needed.
“*” means: This item of maintenance should be carried out at a service center. It may be also
done by the user with reference to this manual provided special tools and authorized spare
parts are used. The user must also be capable of completing the procedure.
“**” means: This item can only be carried out by an authorized service center
in order to ensure safety.
Notes:
1. Maintenance should be conducted more frequently when the motorcycle is driven in
dusty areas.
2. When the vehicle has exceeded the maximum figures specified in the table, maintenance
should be still cycled according to the intervals of mileage stated herein.
INSPECTION AND MAINTENANCE
It is very important to inspect and maintain your dirt bike regularly.
Follow the guidelines in the chart. The intervals between periodic services in months are
shown. At the end of each interval be sure to perform the maintenance listed.
To Next Page
Loading...