Quietside DPW-099A - Venting Precautions

87 pages

Save Page as PDF

To Next Page

To Previous Page

Concentric Vent Termination

37 (11.3meters)

of Typical Venting & Non-direct Venting & Snorkel Venting

ESC

Main Page

Contents1
Safety Warnings2
Names of Components8
The Water Heater Indication9
Proper Operation10
Before Operation10
When in Use11
Management in Case of Gas Leak11
Cautions to Prevent Freezing During the Winter Months12
When Not Using the Unit for Short-Term (2-3 Days)13
Long Term Non-Use14
Temperature Control Indicator & Button Function (DSR-100F)15
When Using "Closed Loop" Button16
When Using "Repeated Timer Setting" Mode17
When Using "Domestic Hot Water" Mode18
Lamp Functions19
Displayed Error Code19
How to Clean the Heating Filter20
Domestic Hot Water Filter Cleaning20
Closed Loop Filter Cleaning22
How to Supply the Water24
Bottom of the Unit24
How to Supply the Water with Pressure Gauge Model-Air Close Type24
Checkpoints before Making Repair Work Order26
Specifications27
Isometric View28
Dpw-009 a & 120A28
Components Diagram28
Case Assembly28
Burner Assembly29
Water Line Assembly30
Part List31
Troubleshooting32
Error Code: "A2" Abnormality of Hall Sensor32
Error Code: "A3" Pump Detection Switch "Made"33
Error Code: "A4" Overheat Thermostat "Open"34
Error Code: "A5" Pump Detection Switch "Open"35
Error Code: "A6" Ignition Failure36
Error Code: "A7" Gas Valve Relay Stuck37
Error Code: "A8" Abnormality of Flame Detection (Pseudo Flame)38
Error Code: "A9" Operation for Freeze Prevention39
Error Code: "Ab" and "Ac" Abnormality of Thermostat39
Error Code: "AA" Prevention of Boiling40
Error Code: "Ad" Blockage of Condensate & Flue System41
Outline Diagram42
How to Install43
How to Attach44
Standard Piping Diagram45
Installation Clearance46
Before Installing46
Clearance Requirements from Vent Terminations to Building Openings47
Flue Plumbing48
Venting48
Vent Terminal Installation Precautions49
Typical (and Recommended) Venting Design50
Installation of Venting System51
The Others Venting Design55
Non-Direct Vent56
Snorkel Flue57
Concentric Vent Termination58
Venting Precautions59
Gas Plumbing60
Pipe Sizing Example61
Natural Gas Supply Piping61
Propane (LP) Gas Supply Piping61
To Turn off Gas to Appliance62
For Your Safety, Rear before Operating62
Domestic Hot Water Plumbing63
Electric Wiring64
Condensate Discharge66
DPW Dip Switch Settings67
Setting for Natural Gas Operation67
Setting for LP Gas Operation67
Unit Options67
Zone Control68
Maximum Firing Rate68
Minimum Firing Rate68
Specific Requirements for Installation in Massachusetts69
Vent Termination Requirements70
Specific Requirements for Installation in Canada71
Combustion and Leak Testing of DPW Units72
Manual Water Fill Valve for Closed Loop System72
Zone Control of DPW Unit73
Anti Freeze & Freeze Protection74
Pump Curves & Primary-Secondary Piping75
Unit Controls & Zoning75
To Set DSR-100F80
Wiring Diagram83

Quietside DPW-099A - Venting Precautions

Table of Contents

Related product manuals