906145
TOUBLESHOOTING
IMPORTANT: only qualified personnel should service internal components.
Should your unit fail to operate properly, check that the electric plug is secure, and that t he hopper contains ice.
If the unit still does not dispense, check the following chare under the appropriate sympt oms to aid in locating
the defect.
Trouble
Probable Cause
BLOWN FUSE OR CIRCUIT BREAKER. A. Short circuit in wiring.
B. Defective gate solenoid.
C. Defective agitator m otor.
GATE DOES NOT OPEN. AGITATOR DOES NOT
TURN.
A. No power.
B. Defective dispensing switch.
C. Bent depressor lever (does not actuate switch).
GATE DOES NOT OPEN OR IS SLUGGISH.
AGIT ATOR TURNS.
A. Excessive pressure against gate slide.
B. Defective gate solenoid.
C. Weak gate spring.
GATE OPENS. AGITA TOR DOES NOT TURN.
A. Ice solidified in hopper.
B. Defective agitator motor.
C. Defective capacitor (T J90 only).
ICE DISPENSES CONTINUOUSLY.
A. Stuck or bent depressor lever (does not release
switch).
B. Defective dispensing switch.
C. Improper switch installation.
SLUSHY ICE. WATER IN HOPPER.
A. Blocked drain.
B. Unit not level.
C. Poor ice quality due to water quality or icemaker
problem.
D. Improper use of flake ice.
Distributed By:
Commercial Refrigeration Service, Inc.
WWW.CorneliusParts.COM
WWW.IceCubes.NET
(623) 869-8881
(866) 423-6253
To Next Page
Loading...