Rheem PRO+G48-60N RH60 User Manual

AP23059 Rev 01
FOR YOUR SAFETY!
— Do not store or use gasoline or other
flammable vapors or liquids or other
combustible materials in the vicinity of this or
any other appliance. To do so may result in an
explosion or fire.
— WHAT TO DO IF YOU SMELL GAS
● Do not try to light any appliance.
● Do not touch any electrical switch; do not
use any phone in your building.
● Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
● If you cannot reach your gas supplier, call
the fire department.
● Do not return to your home until authorized
by the gas supplier or fire department.
— Improper installation, adjustment, alteration,
service or maintenance can cause property
damage, personal injury, or death. Refer to
this manual. Installation and service must be
performed by a qualified installer, service
agency or the gas supplier.
WARNING: If the information in these instructions is not followed exactly,
a fire or explosion may result causing property damage, personal injury or death.
The purpose of this manual is twofold: one, to provide the installer with the basic directions
and recommendations for the proper installation and adjustment of the water heater; and two,
for the owner–operator, to explain the features, operation, safety precautions, maintenance and
troubleshooting of the water heater. This manual also includes a parts list.
It is imperative that all persons who are expected to install, operate or adjust this water heater
read the instructions carefully so they may understand how to perform these operations. If you
do not understand these instructions or any terms within it, seek professional advice.
Any questions regarding the operation, maintenance, service or warranty of this water heater
should be directed to the seller from whom it was purchased. If additional information is
required, refer to the section on “If you need service.”
Do not destroy this manual. Please read carefully and keep in a safe place for future
reference.
Recognize this symbol as an indication of Important Safety Information!
Use & Care Manual
With Installation Instructions for the Installer
Water Heaters
Residential Gas - FVIR Certified
WARNING: This water heater is not suitable
for use in manufactured (mobile) homes!
!
!
!
El manual en Español está disponible en www.rheem.com.

Rheem PRO+G48-60N RH60 Specifications

General

Type	Gas
Capacity	60 gallons
Height	60 inches
Energy Factor	0.67
BTU Input	40, 000 BTU
Fuel Type	Natural Gas
Warranty	6 years
Diameter	22 inches

Summary

Residential Gas - FVIR Certified Water Heaters

FOR YOUR SAFETY!

General safety and emergency procedures for gas leaks.

IMPORTANT SAFETY INFORMATION.

ADANGER! INSTALL THE DRAFT HOOD AND PROPERLY VENT THE WATER HEATER...

Safety regarding draft hood and venting.

AWARNING! Gasoline, as well as other flammable materials...

Warning about flammable materials.

ADANGER! WATER TEMPERATURE SETTING

Time/Temperature Relationship in Scalds

Chart showing scald risk based on water temp.

ADANGER! LIQUEFIED PETROLEUM (LP - PROPANE OR BUTANE) AND NATURAL GAS MODELS

WHAT TO DO IF YOU SMELL GAS

Emergency steps for gas leaks.

SAFETY PRECAUTIONS

FOR INSTALLATIONS IN THE STATE OF CALIFORNIA

Specific installation safety for California.

Installing the water heater.

Location

Requirements for water heater placement.

Minimum clearance from combustible construction

Table of required clearances.

Combustion and Ventilation Air

Air requirements for proper operation.

Corrosive Atmospheres

Warning about environments affecting the heater.

Water Supply Connections

How to connect water lines.

Thermal Expansion

Managing pressure changes from heating water.

Relief Valve

Installation and function of the T&P relief valve.

To Fill the Water Heater

Procedure for filling the tank.

Gas Supply

Requirements for gas line connections.

Leak Testing

How to check for gas leaks.

High Altitude

Considerations for installation at high altitudes.

Venting

Proper installation of the venting system.

Insulation Blankets

Guidance on external insulation blankets.

Hot and Cold Pipe Insulation Installation

Instructions for insulating pipes.

Heat Trap

Information on heat traps for energy efficiency.

During Installation of this water heater

DO/DON'T checklist for installation.

Installation Checklist

A. Water Heater Location

Checklist items for location.

B. Water Supply

Checklist items for water supply.

C. Gas Supply

Checklist items for gas supply.

D. Relief Valve

Checklist items for relief valve.

E. Venting

Checklist items for venting.

Supplemental instructions for gas water heaters installed in potable/space heating applications.

Combination Potable and Space Heating Application

Safety and installation for dual use.

ADANGER: When this system requires water for space heating...

Scald hazard warning for dual use.

Lighting the water heater.

FOR YOUR SAFETY READ BEFORE OPERATING

Safety warnings before operating.

LIGHTING INSTRUCTION

Step-by-step guide to lighting the pilot.

TO TURN GAS OFF TO THE APPLIANCE

Procedure to shut off gas.

Operating the water heater.

Safety Precautions

General safety guidelines during operation.

Water Temperature Setting

How to set water temperature.

Time/Temperature Relationship in Scalds

Chart showing scald risk.

Water Temperature Setting

Continued details on temperature setting.

Care and cleaning of the water heater.

Draining the Water Heater

Procedure for emptying the tank.

Routine Preventative Maintenance

Recommended maintenance.

Housekeeping

Maintaining a safe operating environment.

Venting System Inspection

Checking the integrity of the vent system.

Burner Inspection

Visual inspection of burners.

Vacation and Extended Shut-Down

Instructions for periods of inactivity.

Anode Rod

Explanation of the anode rod's function.

Before You Call For Service...

Troubleshooting Tips

General intro to troubleshooting.

Condensation

Troubleshooting condensation issues.

Yellow flame or soot

Diagnosing yellow flame or soot.

Unable to light the pilot burner

Steps to troubleshoot pilot ignition failures.

Rumbling noise

Addressing tank rumbling and popping noises.

Not enough or no hot water

Diagnosing and fixing lack of hot water.

Water is too hot

Addressing issues with excessively hot water.

Replacement Parts.

Instructions For Placing a Parts Order

Guide for ordering replacement parts.

IF YOU NEED SERVICE

Contacting the Manufacturer

Information for reaching the manufacturer's service department.