Savannah Heating BCF36 - Default Chapter; Table of Contents

Page 3 of 68
Table of Contents
IMPORTANT SAFETY INFORMATION …………………………………………………………….. 4 – 5
1.0 INTRODUCTION .....................................................................................................................
1.1 Specifications, Appliance Dimensions & Installation Codes ................................. 6 - 7
1.2 Features, Remote Control Functions .................................................................. 8 - 10
1.3 Intended Use ............................................................................................................ 11
1.4 General Safety .................................................................................................. 11 - 12
2.0 OPERATION ...........................................................................................................................
2.1 Lighting Instructions ......................................................................................... 13 – 16
2.2 Heat Output adjustment……………………………………………………………………17
2.3 Fan Operation…………………………………………………………………………17 - 18
3.0 INSTALLATION ......................................................................................................................
3.1 Installation & Safety Notes ...................................................................................... 19
3.2 Unpacking ................................................................................................................ 19
3.3 Installation ............................................................................................................... 19
3.3.1 Minimum Clearances & Non Combustible Material Requirements .................. 20 - 22
3.3.2 Gas Line Installation ................................................................................................ 23
3.3.3 Thermostat,Wall Switch or Digital On/Off Remote………………………………..24 - 25
3.3.4 Direct Vent Information .................................................................................... 26 - 37
3.3.5 Ceramic Logs & Rock & Glass Installation ....................................................... 38 - 42
3.3.6 Door Installation ................................................................................................ 43 - 45
3.3.7 Initial Firing .............................................................................................................. 45
3.3.8 Manifold Pressure ..................................................................................................... 46
3.3.9 Primary Air Adjustment .................................................................................... 46 - 47
3.3.10 Altitude Adjustment .................................................................................................. 47
3.3.11 Fan Access ....................................................................................................... 47 - 48
3.3.12 Gas Valve Access .................................................................................................... 49
4.0 MAINTENANCE .....................................................................................................................
4.1 Maintenance Safety ................................................................................................. 50
4.2 Recommended Service ........................................................................................... 50
4.3 Glass Cleaning ........................................................................................................ 51
4.4 Burner & Pilot Cleaning ........................................................................................... 51
4.5 Valve & Pilot Replacement ............................................................................. 51 - 52
5.0 TROUBLE SHOOTING ……………………………………………………………….……. 53 - 56
6.0 REPLACEMENT PARTS ………………………………………………………………………...57
7.0 WARRANTY .………………………………………………………………………………....58 - 60
8.0 LABEL INFORMATION .………………………………………………………………….…61 - 62
APPENDIX A (INTERMITTENT PILOT & VALVE KIT)……………………....………………….63 – 66
APPENDIX B (NG – LP CONVERSION KITS)........................................................................66 - 68