METIS M311 / M322 / H311 / H322 (17-pin)
Content
3
5.6.3 Calculation of the Spot Size Diameter outside the Focused Distance .............................. 19
6 Pyrometer Parameters / Settings .................................................................................................. 20
6.1 Emissivity Slope ...................................................................................................................... 20
6.2 Emissivity ε (when used in single-channel mode) .................................................................. 20
6.3 Transmittance ......................................................................................................................... 21
6.4 Spot Size Fill Factor ................................................................................................................ 21
6.5 Switch-off Level ....................................................................................................................... 21
6.5.1 Switch-off Verification ........................................................................................................ 22
6.5.2 Dirty Window Alarm ........................................................................................................... 22
6.6 Response Time t
90
.................................................................................................................. 22
6.6.1 Dynamic Adaptation at Low Signal Levels (only M3) ........................................................ 22
6.7 Maximum Value Storage (Peak Picker) / Clear Time t
CL
........................................................ 22
6.8 Temperature Sub Range ........................................................................................................ 23
6.9 Customize Analog Output ....................................................................................................... 23
6.10 Analog Output ......................................................................................................................... 23
6.10.1 Test Current ....................................................................................................................... 23
6.10.2 Upscale-Burnout ................................................................................................................ 23
6.11 Interface Type (only M3) ......................................................................................................... 24
6.12 Baud Rate ............................................................................................................................... 24
6.13 Temperature Unit .................................................................................................................... 24
6.14 Address ................................................................................................................................... 24
6.15 Interface Delay / Answer Delay .............................................................................................. 24
7 SensorTools Software .................................................................................................................... 25
7.1 Program Start / Connecting the Pyrometer ............................................................................ 25
7.2 Software Window .................................................................................................................... 27
7.2.1 Main Window Graphs .................................................................................................... 27
7.2.2 Control Window ................................................................................................................. 30
7.2.3 Device Settings and Configuration .................................................................................... 32
7.2.3.1 Digital Input / Output Configuration .............................................................................. 33
7.2.3.2 Service functions .......................................................................................................... 35
7.2.3.3 Interface ........................................................................................................................ 35
7.2.3.4 Data Collection (Buffer Mode) ...................................................................................... 36
7.2.3.5 Single-Point Adjustment ............................................................................................... 37
7.2.4 PID Controller .................................................................................................................... 39
7.2.5 Setups ................................................................................................................................ 41
7.3 Data Playback ......................................................................................................................... 42
7.4 Communication / Options ....................................................................................................... 43
7.5 Spot Size Calculator ............................................................................................................... 43
8 SensorFlash Software (Update Firmware) .................................................................................... 44
9 Technical Data ................................................................................................................................. 45
9.1 Storage ................................................................................................................................... 46
9.2 Dimensions ............................................................................................................................. 47
9.3 Composition of the Type Number ........................................................................................... 48
9.4 Accessories ............................................................................................................................. 49
10 Maintenance..................................................................................................................................... 50
10.1 Cleaning .................................................................................................................................. 50
10.2 Pyrometer Calibration ............................................................................................................. 50
10.3 Trouble-Shooting .................................................................................................................... 50
11 Communication via Serial Interface / Interface Commands ....................................................... 51
Index ......................................................................................................................................................... 56