Home
Shihlin electric
Inverter
SC3-043-1.5K
Shihlin electric SC3-043-1.5K - User Manual
202 pages
Manual
Specs
Ask a question
Save Page as PDF
To Next Page
To Next Page
Loading...
Shihlin Electric General Inverters
SC3 Series
User Manual
SC3-
02
1-
0.
2K
～
2.2
K
SC3-
023
-
0.
2K
～
3.7
K
SC3-
043
-
0.
4K
～
5.5K
MANUAL
GUIDE
1
DELIVERY AND INSPECTION
2
INVERTER INTRODUCTION
3
PRIMARY
OPERATION
4
PARAMETER DESCRIPTION
5
INSPECTION AND MAINTENANCE
6
APPENDIX
7
2
Table of Contents
Main Page
Table of Contents
1
Manual Guide
3
Inverter Introduction
4
Primary Operation
4
Parameter Description
5
Inspection and Maintenance
7
Appendix
7
Definitions of Terminologies
9
Delivery Check
10
Inverter Introduction
11
Vseries Three-Phase
12
Vseries Single-Phase
13
General Specification
14
Appearance and Dimensions
15
Frame B
16
Name of each Component
17
Installation and Wiring
18
EMC Installation Instructions
20
Peripheral Devices
21
No-Fuse Switch and Magnetic Contactor
22
Brake Resistor
23
Terminal Wire Arrangement
24
Main Circuit Terminals
25
Main Circuit Wiring and Terminal Specification
26
Ground
27
Control Circuit
28
Replacement Procedure of Fan
33
Primary Operation
34
Operation Modes of the Inverter
35
The Flow Chart for Switching the Operation Mode
36
The Operation Flow Charts for Monitoring Mode
37
Operation Flow Charts for Parameter Setting Mode
38
Basic Operation Procedures for Different Modes
39
Basic Operation Procedures for JOG Mode (00-16(P.79)＝0 or 1)
40
Basic Operation Procedures for Combined Mode 2 (00-16(P.79)＝5)
41
Basic Operation Procedures for Combined Mode 3 (00-16(P.79)＝6)
42
Basic Operation Procedures for Combined Mode 5 (00-16(P.79)＝8)
43
Operation
44
Trial Run
45
Parameter Description
46
Inverter Information
49
Parameter Restoration
50
Parameter Protection
52
Monitoring Function
55
Speed Display
56
The Setting Frequency Selection of Rotary Knob on the Operating Keyboard
57
Stop Operation Selection
58
Forward/Reverse Rotation Prevention Selection
59
Operation Mode Selection
60
Hz Switch Selection
61
Parameter Mode Setting
62
Basic Parameter Group01
63
Limiting the Output Frequency
65
Base Frequency, Base Frequencyvoltage
66
Acceleration/Deceleration Time Setting
67
Starting Frequency
69
JOG Operation
72
Frequency Jump
73
The Second Function
74
S Pattern Time
76
Analog Input and Output Parameter Group 02
78
Proportion Linkage Gain
79
Auxiliary Frequency
80
Selection and Handling of Input Terminal 3-5
81
Output Current According to the Benchmark
87
Digital Input/Output Parameter Group03
88
Function Selection of Digital Input
91
Function Selection of Digital Output
94
Terminal Logic Selection
95
Output Signal Delay
96
Digital Input Terminal Power Enable
97
Zero Current Detection
98
Multi-Speed Parameter Group04
99
Speeds
101
Programmed Operation Mode
103
Motor Parameter Group05
107
Motor Parameter Auto-Tuning Function Selection
108
Motor Parameter
110
Protection Parameter Group06
111
Electronic Thermal Relay Capacity
113
Regenerative Brake
114
Over Torque Detection
115
Cooling Fan Operation
116
Time Record Function
117
Communication Parameter Group 07
119
Shihlin Protocol and Modbus Protocol
120
Writing Selection of Communication EEPROM
137
PID Parameter Group08
139
PID Function Selection
140
Application Parameter Group 10
145
DC Injection Brake
148
Zero-Speed/Zero-Servo Control
149
Restart Mode Selection
150
Remote Setting Function Selection
151
Retry Selection
153
The Dead Time of Positive and Reverse Rotation
154
Reciprocating Engine Function
158
Speed and Torque Control Parameter Group 11
160
Special Adjustment Parameter Group13
161
User Parameter Group 15
162
User Registration Parameters
163
Inspection and Maintenance
164
Cleaning
165
Measurement of Main Circuit Voltages, Currents and Powers
166
Measurement of Power
167
Appendix
168
Appendix 2 Alarm Code List
186
Appendix 3 Troubles and Solutions
189
Appendix 4：Optional Accessories
190
DU06 Operation Panel
192
DU08 Operation Panel
193
Du10Operation Panel
195
CBL: Data Transmission Line (Coordinated with the Operation Panel)
196
Appendix 6 European Specification Compatibility Description
198
Revision Record
202
Need help?
Do you have a question about the Shihlin electric SC3-043-1.5K and is the answer not in the manual?
Ask a question
Shihlin electric SC3-043-1.5K Specifications
General
Brand
Shihlin electric
Model
SC3-043-1.5K
Category
Inverter
Language
English
Related product manuals
SC3-043-7.5K/11KF
217 pages
Shihlin electric SC3-043-2.2K
202 pages
Shihlin electric SC3-043-0.75K
202 pages
Shihlin electric SC3-021-0.75K
202 pages
Shihlin electric SC3 Series
217 pages
Shihlin electric SF Series
145 pages
Shihlin electric SS2 Series
176 pages
Shihlin electric SE2 Series
160 pages
Shihlin electric SF-040-22K
145 pages
Shihlin electric SS2-023-0.4K
176 pages
Shihlin electric SS2-043-2.2K
176 pages
Shihlin electric SS2-021-1.5K
176 pages
Need help?
General
To Next Page