Ski-Doo 2005 ZX series

To Next Page

Mmo-2005 ZX REV ang.FH8 Tue Mar 30 09:28:26 2004 Page 1

Composite

C M Y CM MY CY CMY K

Main Page

Default Chapter2
- Safety Warning2
- Table of Contents5
Safety Measures9
- Safety Information13
Introduction14
- Safety Information14
Safety Labeling15
A Word to All Snowmobilers17
- Traction Enhancing Products18
Laws and Regulations24
Summary of Accident Prevention Practices25
Passenger Safety Basics29
Environment30
- Vehicle Information33
Frequently Asked Questions34
Authorized Ski-Doo Dealers36
How to Identify Your Snowmobile37
- Vehicle Description Decal37
- Serial Numbers38
- Engine Serial Number Location39
On-Vehicle Important Instructions41
Controls/Instruments/Equipment60
- 1 Throttle Lever64
- 2 Brake Lever64
- 3 Parking Brake Lever64
- 4 Brake/Parking Brake Pilot Lamp (Red)65
- 5 Gear Shift Lever66
- 6 START/RER Button67
- 7 Reverse Pilot Lamp69
- 8 Handlebar69
- 9 Holding Strap83
- 10 Ignition Switch84
- 11 Tether Cut-Out Switch85
- 12 DESS Pilot Lamp88
- 13 Engine Cut-Out Switch89
- 14 Headlamp Dimmer Switch91
- 15 High Beam Pilot Lamp (Blue)91
- 16 Oil Pilot Lamp91
- 17 Low Battery Voltage Pilot Lamp91
19 Rewind Starter Handle92
20 Choke Lever92
- 18 Engine Management System (EMS) Pilot Lamp92
21 Speedometer93
22 Mode Button96
23 Odometer96
24 Trip Meter97
25 Resetable Hourmeter97
26 Tachometer98
27 Fuel Tank Cap/Gauge98
28 Mechanical Fuel Level Gauge99
29 Electric Fuel Level Gauge101
30 Temperature Gauge102
31 Engine Overheat Warning Lamp (Red)102
32 Heating Grip Switch103
33 Heating Throttle Lever Switch103
34 Rear Passenger Heating Grip Switch103
35 Seat Strap105
36 Rear Grab Handles105
37 Adjustable Backrest106
38 Electric Visor Jack Connector107
12 Volt Power Outlet110
40 Windshield110
41 Adjustable Mirrors110
42 Adjustable Toeholds110
43 Heated Carburetor Valve111
44 Hood and Side Panel Latches112
45 Fuses116
46 Front Grab Handle/Front Bumper124
47 Hood Grills125
48 Storage Compartment127
49 Rear Rack129
50 Tool Kit129
51 Suitcase131
52 Integrated Bag134
53 Seat135
55 Spark Plug Holder141
56 Spare Drive Belt Holder142
57 Hitch142
58 Shields and Guards143
- Guidelines to Adjust Suspension144
  - Track169
59 Convertible Ski Stance143
60 Adjustable Suspensions143
Fuel and Oil170
- Recommended Fuel170
- Recommended Oil171
Cold Weather Carburetion Modifications174
Break-In Period175
- Engine175
- Belt175
- 10-Hour Inspection175
Pre-Operation Check176
Pre-Operation Check List178
Operating Instructions179
- Principle of Operation179
- Starting the Engine180
- Emergency Starting184
- Shutting off the Engine187
Vehicle Warm-Up188
Riding the Vehicle189
How to Ride190
Terrain/Riding Variations194
Post-Operation Care202
Special Operations203
- Riding at High Altitudes203
- Engine Overheating203
- Fuel Flooded Engine203
- Rear Suspension Slider Shoe Sticking204
- Maintenance Information205
Periodic Maintenance Chart206
Fluid Levels209
- Brake System209
- Chaincase/Gearbox Oil Level210
- Oil Injection System211
- Engine Oil Level212
- Cooling System213
- Battery Electrolyte215
Maintenance for Epa Certified Engines216
- Engine Emissions Information216
Maintenance218
- Vehicle Cleaning and Protection218
- Belt Guard Removal and Installation219
- Drive Belt Removal/Installation223
- Drive Chain Tension228
- Drive Pulley Adjustment229
- Drive Belt Condition232
- Brake Condition232
- Brake Adjustment232
- Rear Suspension Condition232
- Suspension Stopper Strap Condition232
- Track Condition233
- Track Tension and Alignment234
- Steering and Front Suspension239
- Wear and Condition of Skis and Runners240
- Exhaust System240
- Air Filter Cleaning240
- Headlamp Beam Aiming244
- Bulb Replacement245
Towing an Accessory249
Towing Another Snowmobile250
Transporting the Vehicle251
Storage and Preseason Preparation252
- Storage252
- Preseason Preparation252
Troubleshooting253
- Monitoring Beeper Coded Signals253
Specifications258
- Warranty267
Brp Limited Warranty North America: 2005 Ski-Doo268
Snowmobiles268
Brp International Limited Warranty: 2005 Ski-Doo274
Snowmobiles274
Privacy Obligations/Disclaimer278
Change of Address or Ownership279

Need help?

Do you have a question about the Ski-Doo 2005 ZX series and is the answer not in the manual?

Ski-Doo 2005 ZX series Specifications

General

Brand	Ski-Doo
Model	2005 ZX series
Category	Offroad Vehicle
Language	English

Related product manuals

Ski-Doo 2005 MACH Z

343 pages

Ski-Doo 2005 SUMMIT HIGHMARK

Ski-Doo Legend SPORT V-1000 2003

Ski-Doo Skandic Series

123 pages

Ski-Doo Expedition Series

179 pages

Ski-Doo 2005 ZX series - User Manual

Table of Contents

Ski-Doo 2005 ZX series Specifications

Related product manuals