Snorkel S3219E - Table of Contents

S3215L/S3215E/S3219E/S3220E/S3226E/S4726E/S4732E – 1500834
Table of Contents
Electrical Danger ............................ Inside Front Cover
Proposition 65 Warning .................. Inside Front Cover
Danger Symbols ............................. Inside Front Cover
Lanyard Anchor Points ................... Inside Front Cover
Safety Rules ................................... Inside Front Cover
Chapter 1 – Introduction
Aerial Platform Features ............................................. 1
Options .......................................................................1
Operator’s Manual ......................................................1
Safety Alerts ...............................................................1
Operation .................................................................... 1
Maintenance ...............................................................2
Used Material Disposal ...........................................2
Manual of Responsibilities – ANSI..............................2
MEWP Safe Use – AS/NZS ........................................ 2
AS/NZS 1418.10 Commissioning ...............................2
CE Compliance...........................................................2
Additional Information ................................................. 2
Chapter 2 – Specications
Component Identication ............................................ 3
General Specications – S3215L ...............................4
General Specications – S3215E ............................... 5
General Specications – S3219E ............................... 6
General Specications – S3220E ............................... 7
General Specications – S3226E ............................... 8
General Specications – S4726E ............................... 9
General Specications – S4732E ............................. 10
Chapter 3 – Safety
Electrocution Hazards .............................................. 11
Minimum Safe Approach Distance – ANSI ............... 11
Minimum Safe Approach Distance – AS/NZS...........12
Platform Capacity .....................................................12
Manual Force............................................................12
Wind Speeds ............................................................12
Prestart Inspection....................................................12
Work Place Inspection and Practices .......................12
Operation .................................................................. 13
Tip-Over and Falling Hazards ...................................13
Electrical System ......................................................14
Hydraulic System......................................................14
Placards and Decals.................................................14
General Safety Rules ...............................................14
Chapter 4 – Safety Devices
Emergency Stop Controls.........................................17
Control Select/Ground Operation Switch..................17
Upper Control Interlock Switch .................................17
Drive Motion Alarm ...................................................18
Pothole Protector Skids ............................................18
Drive/Lift Pothole Protector Interlock ........................18
Drive/Lift Level Sensor Interlock ............................... 18
Progressive Tilt – S3226E Only ............................18
Lowering Alarm ......................................................... 19
Emergency Lowering Lever/Handle .........................19
Safety Prop ............................................................... 19
Guardrails .................................................................20
Ground Fault Circuit Interrupter ................................ 20
Tilt Alarm ...................................................................20
Overload Protection .................................................. 20
Lowering Interrupt – CE/AS/NZS ................................... 20
Horn .......................................................................... 21
Flashing Light ...........................................................21
Snorkel Guard ..........................................................21
Chapter 5 – Gauges and Displays
Battery Charge Indicator – ProCharger ....................23
Battery Charge Indicator – Pylon..............................23
Battery Condition Indicator .......................................23
Diagnostic Center Display ........................................24
Chapter 6 – Batteries
General Maintenance ...............................................25
Charging ...................................................................25
Chapter 7 – Controls
Battery Disconnect ...................................................27
Lower Controls .........................................................27
Emergency Stop Button ........................................27
Control Selector/Ground Operation Switch ...........27
Platform Raise/Lower Switch ................................27
Upper Controls .........................................................28
Emergency Stop Button ........................................28
Drive/Lift Selector Switch ......................................28
Joystick .................................................................28
Interlock Switch .....................................................29
Steer Switch ..........................................................29
Drive Range Switch ............................................... 29
Horn Button ...........................................................29
Battery Condition Indicator ....................................29
Loading Controls ......................................................29
Emergency Stop Button ........................................29
Interlock Button .....................................................30
Drive Switch ..........................................................30
Steer Switch ..........................................................30
Override Switch .....................................................30
Chapter 8 – Prestart Inspection
Operator’s Manual ....................................................31
Electrical System ......................................................31
Battery Fluid Level ................................................31
Battery Terminals ...................................................32
Battery Charger .....................................................32
Safety Prop ............................................................... 32
Cables and Wiring Harness ...................................... 33
Hydraulic System......................................................33
Fluid Level .............................................................33
Hoses, Tubes, and Fittings .................................... 33
Free-Wheeling Valve .............................................34
Diagnostic Center Display ........................................34
Tires and Wheels ......................................................34
Ground Strap ............................................................34