Sony HBD-DZ610 User Manual

SERVICE MANUAL
Sony Corporation
Audio&Video Business Group
Published by Sony Techno Create Corporation
HBD-DZ170/DZ171/DZ175/DZ310/
DZ510/DZ610/DZ810
SPECIFICATIONS
DVD RECEIVER
9-889-740-01
2010A04-1
©
2010.01
US Model
HBD-DZ170/DZ171/DZ175
Canadian Model
HBD-DZ175
E Model
HBD-DZ310/DZ510/DZ610/DZ810
Ver. 1.0 2010.01
• HBD-DZ170/DZ171/DZ175/DZ310/DZ510/DZ610/DZ810
are the amplifi er, DVD/CD and tuner section in DAV-DZ170/
DZ171/DZ175/DZ310/DZ510/DZ610/DZ810.
Model Name Using Similar Mechanism HCD-FZ900KW/FZ900M
Mechanism Type CDM85MB-DVBU102
Optical Pick-up Name KHM-313CAA
This system incorporates with Dolby* Digital and Dolby Pro Logic (II)
adaptive matrix surround decoder and the DTS** Digital Surround System.
* Manufactured under license from Dolby Laboratories.
Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby
Laboratories.
** Manufactured under license under U.S. Patent #’s:
5,451,942; 5,956,674; 5,974,380; 5,978,762; 6,487,535 & other U.S. and
worldwide patents issued & pending. DTS and DTS Digital Surround
are registered trademarks and the DTS logos and Symbol are trademarks
of DTS, Inc. © 1996-2008 DTS, Inc. All Rights Reserved.
AUDIO POWER SPECIFICATIONS
for the U.S. model
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION:
(FTC)
Front L + Front R With 3 ohms loads, both
channels driven, from 180
- 20,000 Hz; rated 84 watts
per channel minimum
RMS power, with no more
than 1% total harmonic
distortion from 250 milli
watts to rated output.
Amplifi er Section
(DAV-DZ170/DAV-DZ171/DAV-DZ175)
U.S. models:
POWER OUTPUT (reference):
Front L/Front R/Center/
Surround L/Surround R:
167 watts (per channel at 3
ohms, 1 kHz)
Subwoofer: 165 watts (at 3
ohms, 80 Hz)
Other models:
POWER OUTPUT (rated):
Front L + Front R 108 W + 108 W (at 3 ohms,
1 kHz, 1% THD)
POWER OUTPUT (reference):
Front L/Front R/Center/
Surround L/Surround R:
167 watts (per channel at 3
ohms, 1 kHz)
Subwoofer: 165 watts (at 3
ohms, 80 Hz)
Inputs (Analog)
TV/CABLE (AUDIO IN) Sensitivity: 450/250 mV
AUDIO IN Sensitivity: 250/125 mV
Inputs (Digital)
TV/CABLE (COAXIAL IN/OPTICAL IN)
Impedance: 75 ohms/-
Input Stream: Dolby
Digital 5.1ch/DTS 5.1ch/
Linear PCM 2ch
(Sampling Frequency: less
than 48 kHz)
Amplifi er Section
(DAV-DZ310/DAV-DZ510/DAV-DZ610/
DAV-DZ810)
DAV-DZ310
POWER OUTPUT (rated):
Front L + Front R 108 W + 108 W (at 3 ohms,
1 kHz, 1% THD)
POWER OUTPUT (reference):
Front L/Front R/Center/
Surround L/Surround R:
142 watts (per channel at 3
ohms, 1 kHz)
Subwoofer: 140 watts (at 3
ohms, 80 Hz)
DAV-DZ510/DAV-DZ610/DAV-DZ810
POWER OUTPUT (rated):
Front L + Front R 108 W + 108 W (at 3 ohms,
1 kHz, 1% THD)
POWER OUTPUT (reference):
Front L/Front R/Center/
Surround L/Surround R:
167 watts (per channel at 3
ohms, 1 kHz)
Subwoofer: 165 watts (at 3
ohms, 80 Hz)
Inputs (Analog)
TV (AUDIO IN) Sensitivity: 450/250 mV
AUDIO IN Sensitivity: 250/125 mV
MIC Sensitivity: 1 mV
Inputs (Digital)
DAV-DZ310:
TV (Audio Return Channel)
Input Stream: Dolby
Digital 5.1ch/DTS 5.1ch/
Linear PCM 2ch
(Sampling Frequency: less
than 48 kHz)
DAV-DZ510/DAV-DZ610/DAV-DZ810:
TV (Audio Return Channel/OPTICAL IN)
Input Stream: Dolby
Digital 5.1ch/DTS 5.1ch/
Linear PCM 2ch
(Sampling Frequency: less
than 48 kHz)
– Continued on next page –
Photo: HBD-DZ170

Sony HBD-DZ610 Specifications

General

Brand	Sony
Model	HBD-DZ610
Category	Receiver
Language	English

Summary

Safety and Repair Precautions

Safety Check-out and Leakage Test (US Model)

Procedures for AC leakage testing and safety checks.

Component Handling Notes

Guidelines for chip component replacement, flexible circuit board repair, and solder.

Self-Diagnosis Function

Model Identification

Table mapping model names to parts numbers and abbreviations.

SECTION 1 Servicing Notes

Handling Optical Pick-up Block

Precautions for handling the optical pick-up block, emphasizing ESD.

Laser Diode Emission Check

Notes and procedures for checking laser diode emission safely.

SECTION 2 Disassembly Procedures

SECTION 3 Test Mode Procedures

Cold Reset

Procedure to clear all RAM data and reset settings to initial conditions.

Panel Test Mode

Modes for checking software version, FL display, and keys.

Product Out Mode

Moves pick-up for shipping and clears data; use when returning to customer.

D.C.A.C. Test Mode

Automatic Acoustic Field Calibration test mode for audio system.

Protection Factor Identification Test Mode

Identifies protection factors (SD, DC, TSD detection) and tests release state.

SECTION 4 Electrical Adjustments

Check Version Information

DVD Section IOP Measurement

Executing IOP measurement for the DVD section after pick-up replacement.

Tuner Section FM Tune Level Check

Procedure for checking FM tuner signal reception levels.

SECTION 5 Diagrams Overview

Printed Wiring Boards

Schematic Diagrams

Block Diagrams - RF Section

Block diagram showing the RF, CD/DVD RF AMP, and DSP sections.

Block Diagrams - Video Section

Block diagram illustrating the video processing and output paths.

Block Diagrams - Audio Section

Block diagram detailing the audio signal flow, including tuner, line amp, and digital inputs.

Block Diagrams - Amplifier Section

Block diagram of the S-MASTER processor and digital power amplifiers for each channel.

Block Diagrams - Power Section

Block diagram illustrating the power supply circuits and regulators.

Printed Wiring Boards - Main Section (1/2)

Printed Wiring Boards - Main Section (2/2)

Schematic Diagrams - Main Section (1/9)

Schematic Diagrams - Main Section (3/9)

Schematic Diagrams - Main Section (4/9)

Schematic Diagrams - Main Section (5/9)

Schematic Diagrams - Main Section (6/9)

Schematic Diagrams - Main Section (7/9)

Schematic Diagrams - Main Section (8/9)

Schematic Diagrams - Main Section (9/9)

Printed Wiring Boards - IO Section

Schematic Diagrams - IO Section

Printed Wiring Boards - JACK, KEY-SW, P-SW Section

Schematic Diagrams - JACK Section

Schematic Diagrams - KEY-SW, P-SW Section

Printed Wiring Boards - SPEAKER, USB, MS-203 Section

Schematic Diagrams - SPEAKER, USB Section

Printed Wiring Boards - FL, ENCODER Section

Schematic Diagrams - FL Section

Schematic Diagrams - ENCODER Section

Printed Wiring Boards - S-AIR CON Section

Schematic Diagrams - S-AIR CON Section

Printed Wiring Boards - POWER Section

Schematic Diagrams - POWER Section

SECTION 6 Exploded Views

6-1. OVERALL SECTION

Exploded view of the entire unit, showing main assemblies and parts.

6-2. FRONT PANEL SECTION

Exploded view of the front panel assembly and its components.

6-3. FRONT BOARDS SECTION

Exploded view showing the FL and encoder boards and related cables.

6-4. BACK PANEL SECTION

Exploded view of the back panel section for different models.

6-5. CHASSIS SECTION

Exploded view of the chassis assembly, including main boards and power board.

6-6. DVD MECHANISM DECK SECTION (CDM85MB-DVBU102)

Exploded view of the DVD mechanism deck and its parts.

SECTION 7 Electrical Parts List

ENCODER FL Section Parts