Sony HBD-TZ715 Service Manual

SERVICE MANUAL
Sony Corporation
Published by Sony Techno Create Corporation
HBD-TZ215/TZ715
SPECIFICATIONS
DVD RECEIVER
9-893-291-01
2011H33-1
©
2011.08
E Model
Ver. 1.0 2011.08
Model Name Using Similar Mechanism HBD-TZ210
Mechanism Type CDM85MB-DVBU102
Optical Pick-up Name KHM-313CAA
• HBD-TZ215 is the amplifi er, super audio CD/DVD,
USB, tuner and video section in DAV-TZ215.
• HBD-TZ715 is the amplifi er, super audio CD/DVD,
USB, tuner and video section in DAV-TZ715.
Photo: HBD-TZ715
Amplifier Section
POWER OUTPUT (rated):
Front L + Front R 65 W + 65 W (at 3 ohms, 1
kHz, 1% THD)
POWER OUTPUT (reference):
Front L/Front R/Center/
Surround L/Surround R:
100 W (per channel at 3
ohms, 1 kHz)
Subwoofer: 100 W (at 3
ohms, 80 Hz)
Inputs (Analog) TV (AUDIO IN)
Sensitivity: 450/250 mV
Super Audio CD/DVD System
Laser Diode Properties Emission Duration:
Continuous
Laser Output: Less than
44.6 PW
* This output is the value measurement at a distance
of 200 mm from the objective lens surface on the
Optical Pi
ck-up Block with 7 mm aperture.
Signal format system
Latin American models: NTSC
Other models: NTSC/PAL
USB Section
(USB) port:
Maximum current: 500 mA
Tuner Section
System PLL quartz-locked digital
synthesizer
Tuning range 87.5 MHz - 108.0 MHz (50
kHz step)
Antenna (aerial) FM wire antenna (aerial)
Antenna (aerial) terminals 75 ohms, unbalanced
Video Section
Outputs VIDEO: 1 Vp-p 75 ohms
HDMI OUT: Type A (19
pin)
General
Power requirements
Latin American models: 110 V - 240 V AC,
50/60 Hz
Other models: 220 V - 240 V AC,
50/60 Hz
Power consumption On: 105 W
Standby: 0.2 W*
* Valid when the system is in the following status:
– “DEMO” is set to “OFF.”
– [CONTROL FOR HDMI] is set to [OFF].
Dimensions (approx.) 430 mm × 67 mm × 335
mm (w/h/d) incl.
projecting parts
Mass (approx.) 3.6 kg
Supported file format
MP3 (MPEG 1 Audio Layer-3)
File Extension: mp3
Bitrate: 32 kbps - 320 kbps
Sampling frequencies: 32/44
.1/48 kHz
WMA (USB device only)
File Extension: wma
Bitrate: 48 kbps - 192 kbps
Sampling frequencies: 44.1 kHz
AAC (USB device only)
File Extension: m4a
Bitrate: 48 kbps - 320 kbps
Sampling frequencies: 44.1 kHz
Xvid
File Extension: avi
Video codec: Xvid video
Bitrate: 4.854 Mbps (MAX)
Resolution/Frame rate: 720 × 480 / 30 fps
720 × 576 / 25 fps
Audio codec: MP3
MPEG4
File format: MP4 File Format
File Extension: mp4/m4v
Video codec: MPEG4 Simple Profile
(AVC is not compatible.)
Bitrate: 4 Mbps
Re
solution/Frame rate: 720 × 576 / 30 fps
Audio codec: AAC-LC (HE-AAC is not
compatible.)
DRM: Not compatible
Design and specifications are subject to change
without notice.
 Standby power consumption 0.2 W.
 Halogenated flame retardants are not used in the
certain printed wiring boards.
 Over 85% power efficiency of amplifier block is
achieved with the full digital amplifier, S-Master.

Sony HBD-TZ715 Specifications

General

Brand	Sony
Model	HBD-TZ715
Category	Receiver
Language	English

Summary

Service Manual Overview

Specifications

Detailed technical specifications for the HBD-TZ215/TZ715 unit.

Model Information

Lists similar models that use the same mechanism type.

Servicing Notes and Precautions

Unleaded Solder Handling

Information on handling and characteristics of unleaded solder.

Optical Pick-up and Laser Diode Handling

Precautions for handling the optical pick-up and checking laser diode emission.

Maintenance Warnings

Warning against using specific cleaning products and potential screen damage.

Disassembly Procedures

Disassembly Flow Overview

A flowchart illustrating the sequence of disassembly steps.

External Component Removal

Procedure for disassembling the outer case, front panel, and loading panel.

Internal Board Removal

Steps for disassembling FL, USB, KEY, P-SW, Main, Power, and FFC Holder boards.

Mechanism and Wire Handling

Procedure for DVD mechanism deck, belt, DC motor, and wire bending.

Back Panel and Power Cord Handling

Steps for disassembling the back panel block and routing the power cord.

Test Modes and Diagnostics

Cold Reset and Panel Test Modes

Procedure for cold reset and panel test modes (version, FL pattern, key tests).

Disc Tray Lock Operation

Procedure to activate and release the disc tray lock function.

Version Display and Test Mode Entry

Displays DVD versions and instructions for entering test modes.

IOP Measurement and Emergency History

Procedure to execute IOP measurement and check the emergency history log.

Electrical Checks and Diagrams

Error Code Meanings and Data Clearing

Explains error codes and procedures for clearing data.

Version Information and Tuner Level Check

Checks software versions and FM tune level.

Block Diagrams Overview

Block diagrams illustrating the unit's functional sections.

Circuit Board Locations and Waveforms

Indicates board locations and displays unit waveforms.

Printed Wiring Board Layouts

Printed wiring board layouts for Main, FL, Key, and Power boards.

Schematic Diagrams

Detailed schematic diagrams for Main, FL, Key, and Power boards.

IC Block Diagrams

Main Board IC Block Diagrams

Block diagrams for ICs on the main board.

Power Board IC Block Diagrams

Block diagrams for ICs on the power board.

IC Pin Function Descriptions

Main Board IC1101 Pin Functions

Pin function description for IC1101 on the main board.

Main Board IC503 Pin Functions

Pin function description for IC503 (System Control) on the main board.

Exploded Views

Overall Assembly Exploded View

Exploded view showing the overall assembly of the unit.

Front Panel Exploded View

Exploded view of the front panel components.

Front Boards Exploded View

Exploded view showing front board assemblies and connections.

Chassis Exploded View

Exploded view of the chassis and main component placements.

DVD Mechanism Deck Exploded View

Exploded view of the DVD mechanism deck components.

Electrical Parts List

Parts List by Board

Parts lists categorized by board (FL, KEY-SW, KZ-USB, etc.).

Common Component Types List

Lists of common component types (Capacitors, Resistors, ICs, etc.).

Revision History