STAR LITHIUM BATTERIES
66 67
7. Lithium Maintenance
Your lithium battery requires very little maintenance. To clean the
battery, wipe it down with a damp cloth. DO NOT spray down or
immerse the battery with water. Yearly; use a 13 mm wrench or socket
to check the main battery terminal bolts for tightness. The main
terminal bolt torque should be 124 in-lb. You will see a 4-pin connector,
located near your battery. Unplug this connector and inspect it for
corrosion every six months.
• For prolonged storage, charge the battery to 100%, unplug the
charger, and you can leave the battery unplugged for 6 months
after fully charging. When you return, the battery should be at
20% charge. Return the battery to full charge at this time.
• Your battery can be safety charged with the key in the OFF position.
8. Operating the Lithium Battery
1. Strongly recommended to charge the battery after each use.
2. Charge the battery as soon as possible when the SOC is <10%
3. Avoid to discharge the battery to < 5%.
4. Strictly follow the operating temperature range below:
— Discharge: -20˜60C (-4˜140F)
— Charge: 0˜50C (32˜122F)
— Storage: 0˜30C (32˜86F)
5. Even if not being used, fully recharge the battery at least once every
3 months, recommended to recharge every month.
6. Fully charge the battery before leaving if for a longer period of time
(with in 3 months)
7. In case used in golf cart, avoid accelerating harshly as it may cause
current spikes, triggering the battery's self-protective cut-off.
9. Storage
1. For storage over one month, turn OFF the devices connected to
the battery and push OUT the battery push button (if applicable)
place the battery in a dry and ventilated location with temperature
between 0˜30C° (32˜86F°)
2. DO NOT store the battery near corrosive material, fire or heat sources.
Fully charge the battery before storage; Fully recharge the battery
every 3 months.
To Next Page
Loading...
