Summary of Important Safety Information for Operation
This section provides a summary of the various safety procedures and measures that have been
presented throughout the manual. Keep this summary handy and refer to it to refresh your
memory about how to safely use your generator.
Carefully read and make sure you understand the following safety information before using the
generator. Improper use or maintenance of the generator can result in serious injury or death from
carbon monoxide poisoning, electric shock, fire/explosion, or burns.
• Read manual. Read this Owner’s Manual and the engine Owner’s Manual completely before
attempting to set-up and use the generator. Serious injury or death can result if safety instructions are
not followed.
• Instruct operators. The generator owner must instruct all operators in safe generator set-up and
operation. Do not allow anyone to operate the generator who has not read the Owner’s Manual and
been instructed on its safe use.
• Adults only. Only trained adults should set up and operate the generator. Do not let children operate.
• Under the influence. Never operate, or let anyone else operate, the generator while under the
influence of alcohol, drugs, or medication.
• Intended use. Carefully read about and understand the intended use of this generator. Do not use for
other purposes, as unforeseen hazards or equipment damage may result.
Safety – Installation & Set-up
Installation / Initial Set-up Safety
• Dry, level surface. Situate generator on a dry, firm, level surface. Ensure generator sits level and
will not slide or shift during operation. Block wheels if applicable.
• Operate OUTSIDE only – dangerous carbon monoxide exhaust! Generators give off carbon
monoxide exhaust, a poisonous gas that can kill. You CANNOT smell it, see it, or taste it. ONLY
run generator OUTDOORS and away from building air intakes. NEVER run generator inside
homes, garages, sheds, or other semi-enclosed spaces. These spaces can trap poisonous gases,
EVEN if you run a fan or open windows. Carbon monoxide is given off whether you are using
petrol, natural gas, or
propane to power the generator.
•
No vehicle/marine use. This generator is NOT designed or approved for use in vehicles or marine
applications. Never run the generator inside RVs or other vehicles, on boats, or on pick-up truck
beds.
• Cooling ventilation. The generator needs adequate, unobstructed flow of air to allow for proper
cooling of engine and generator head. Situate so there is adequate clearance around generator to
allow for cooling airflow. Do not allow debris to accumulate and block airflow.
• Grounding. Always ensure generator is properly grounded to prevent electrical shock. This
generator is equipped with a grounding post. Always complete the grounding path from the
generator to a copper pipe/rod driven into moist earth to a sufficient depth. Check with an
electrician for local grounding requirements. If a
Prohibition Against Modifications!
Never modify or alter the generator in any way. Modifications can create serious safety hazards and will also
void the warranty.
• Engine speed. Never attempt to modify the engine speed setting. The engine speed is preset at 3600 RPM
for safe and optimal performance of the generator. If speed needs adjusting, it must be done by factory
authorized personnel.
• Fuel/exhaust system. Never modify the exhaust system, fuel tanks, or fuel lines. Carbon monoxide
poisoning, fire, or explosion could result.
• Guards. Do not operate generator unless all guards and cover shields, which prevent access to moving
parts and pinch points, are in place. Failure to guard the power transmission mechanisms may result in
serious injury or death.
To Next Page
Loading...