Sullair 1809e - Installation; Compressor Mounting Procedures; Ventilation and Cooling Requirements

SECTION 3 1100E, 1500E, 1800E USER MANUAL
31
3.6 PIPING AND INSTRUMENTATION, AIR-COOLED
KEY
NO.
PART NO.
Q
T
Y
DESCRIPTION
N
O
T
E
1 02250125-365 1 FILTER,AIR INLET 6” (PLASTIC)
2 - 1 VALVE, GROUP INLET DXX102E
3 MTR_VAR 1 MOTOR
4 - 1 COMPRESSOR
5 02250157-679 1 TUBE, SEP OIL RETURN ES8
6 02250106-789 1 ELEMENT, SEPARATOR AIR/OIL
7 02250046-338 1 VALVE, MIN PRESS GROUP E08E
8 02250154-741 1 COOLER, AIR/OIL ES8 15-25 HP
9 02250166-732 1 SEP, WTR SCWS-85N 3/4” L/AD
10 02250156-599 1 FILTER, CORELESS M27 3” L
11 02250092-081 1 VLV, THERMAL 195F 1-1/2-18
12 02250155-174 2 XDCR, PRESS 0-250 PSI 1-5 VDC N4
13 250006-938 1 VALVE, RELIEF 1/2” 200#
14 02250155-175 1 PROBE, THERMISTER 3000 OHM NTX
6”L
15 02250049-634 1 VLV, BLWDN 1/4 HI PRES
16 02250173-972 2 FLTR, PNEUMATIC 1/8”NPT 5MICRON
17 02250155-714 2 VALVE, SOL 3WNO 1/4 235# N4
18 250017-280 1 VALVE, PRESSURE REGULATOR
19 408893 1 VALVE, SHUTTLE 1/4” (DBL CHK)
20 02250170-783 1 VLV, DR COMBO 24 VDC
21 02250097-610 1 PLUG, SIGHT GLASS 1 5/16” SAE
22 - 1 ROTOR INLET END BEARINGS
23 - 1 FEMALE INJECTION
24 - 1 GEAR LUBE SUPPLY
25 02250097-611 1 PLUG, SIGHT GLASS 1 7/8” SAE
26 - 1 FEMALE BLOCKING
27 - 1 MALE BLOCKING
28 - 1 GEAR BOX
29 02250061-862 1 HTR, BAND SCOW 115V (OPTIONAL)
PLEASE NOTE: WHEN ORDERING PARTS,
INDICATE SERIAL NUMBER OF COMPRESSOR
Notes:
1. Part numbers are for reference only. Refer to bill of material and
or face of order for actual parts.
2. Section between lettered points are to be replaced with corre-
sponding option pictured below, as required by face of order.
3. Control/moisture drain lines are 1/4" tubing except as noted.
30 02250118-589 1 ORF, .125” .25FNPT .25 MNPT
31 02250078-249 1 SW,VAC 22”WC N4 6FT CABLE 5A
32 02250050-154 1 SW, DIFF PRESS 20 PSID
33 02250144-842 1 VALVE, BALL/STNR COMB 1/2F X 1/2M
34 02250130-866 1 DRN,ELECTRIC CONDENSATE SCD400
35 02250169-612 1 GA,DIFF PRESS Z-PRG ASY BTM
36 02250168-837 1 VENT,ENCL PROT 1/2” TOP
37 241771 1 STRAINER,V-TYPE 300PSIX1/4
COMPONENT DESCRIPTION
P1 WET SUMP PRESSURE
P2 LINE PRESSURE
DPSW1 FLUID FILTER DIFFERENTIAL SWITCH
PSW1 INLET AIR FILTER SWITCH 22” WC (558.9mm WC)
SOL1 LOAD/UNLOAD SOLENOID VALVE
SOL4 MEC/SEQUENCING/FULL LOAD SOLENOID VALVE
SOL5 ELECTRIC DRAIN SOLENOID VALVE
T1 WET DISCHARGE TEMPERATURE
KEY
NO.
PART NO.
Q
T
Y
DESCRIPTION
N
O
T
E
PLEASE NOTE: WHEN ORDERING PARTS,
INDICATE SERIAL NUMBER OF COMPRESSOR