Sullair LS-20 - Entrapment Prevention

TABLE OF CONTENTS
(CONTINUED)
Section 5
COMPRESSOR
Page
SYSTEMS (cont.)
14
5.5 COMPRESSOR DISCHARGE SYSTEM,
FUNCTIONAL DESCRIPTION
17
5.6 CON TRO L SYSTEM, FUNCTIONAL DESCRIPTION
22
5.7 AIR INLET SYSTEM, FUNCTIONAL DESCRIPTION
Section 6
COMPRESSOR
OPERATION
23
6.1 INTRODUCTIO N
23
6.2 PURPOSE OF CONTROLS
24
6.3 SUPERVISOR II OPERATING PARAMETERS -- SETUP
25
6.4 DELUXE PARAMETER SETUP
25
6.5 OPERATING THE COMPRESSOR
26
6.6 PURPOSE OF CONTROLS
26
6.7 SU PERVISOR II OUTPUT RELAYS
27
6.8 MOTOR ROTATION CHECK
27
6.9 INITIAL SHUTDOWN PROCEDURE
27
6.10 SUBSEQUENT START--UP PROCEDURE
27
6.11 SHUTDOWN PROCEDURE
Section 7
MAINTENANCE
29
7.1 GENERAL
29
7.2 DAILY OPERATION
29
7.3 MAINTENANCE AFTER INITIAL 50 HOURS
OF OPERATION
29
7.4 MAINTENANCE EVERY 1000 HOURS OF OPERATION
29
7.5 PARTS REPLACEMENT AND ADJUSTMENT
PROCEDURES
29
AIR FILTER MAINTENANCE
30
FLUID FILTER MAINTENANCE
30
SEPARATOR ELEMENT MAINTENANCE
31 SHAFT COUPLING MAINTENANCE
Section 8
TROUBLESHOOTING
33
8.1 INTRODUCTION
33
8.2 TROUBLESHOOTING
34
8.3 CALIBRATION