Sullair VCC-200S - Page 101

Section 10
ILLUSTRATIONS AND PARTS LIST
95
10.16 PNEUMATIC CONTROLS- V-200S
key part
number description number quantity
1 regulator, reducing 1/4 npt (I) 02250046-568 1
2 tube, nyl .25od x 040w blk 02250054-861 1
3 locknut, n4 conduit sealing 02250071-362 2
4 valve, 1/2 bldwn 1.8:1 250 psig (II) 02250100-042 1
5 gage, air press 2 1/2” 0-200 psi 02250117-009 1
6 valve, solenoid 3wno 1/4 235# n4 (III) 02250125-657 2
7 orifice, cap .031” x 1/4” npt 02250132-934 1
8 support, brkt strainer ls200s 02250146-346 1
9 strainer, v-type 300psix1/4 (IV) 241771 2
10 nipple, brass hex 1/4”-npt 249537 3
11 hose, med press .50 x 24” 249608-005 1
12 connector,1/4”tube x 1/4”npt 250018-428 3
13 elbow, 90 1/4”tube x 1/8”npt 250018-429 1
14 elbow, 1/4” tube x 1/4” npt 250018-430 6
15 connector, straight 1/4t plsx 1/4npt f 250041-084 4
16 valve, shuttle 1/4” npt (dbl chk) 408893 1
17 nut, hex f pltd 1/4-20 825304-236 2
18 screw, hex ser washer 1/4-20 x 3/4 829704-075 2
19 bulkhead, pipe 1/4” npt 841500-004 2
20 nipple, chase cond 1/2 847815-050 2
21 connector, 37 fl/mpt pltd 1/2 x 1/2 860108-050 1
22 elbow, 37fl 90m 1/2 x 1/2 860208-050 1
23 elbow, pipe-90m 1/4 x 1/4 860504-025 1
24 elbow, pipe 90 deg plt 1/4” 866215-010 2
25 nipple, pipe-hx pltd 1/2 x 1/2 868508-050 1
26 tee, male pipe brass 1/4 869825-025 4
(I) For maintenance on reducing regulator valve no. 02250046-568, order repair kit no. 02250055-911.
(II) For maintenance on blowdown valve no. 02250100-042, order repair kit no. 02250142-132.
(III) For maintenance on solenoid valve no. 02250125-657, order repair kit no. 02250125-829, and replace-
ment coil no. 02250125-861.
(IV) For maintenance on strainer no. 241771, order repair kit no. 241772.
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR