Superior DR-600CMN - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

General Information and Safety

Installation and Repair Personnel

Specifies that installation and repair should be performed by qualified personnel.

Clearances and Appliance Location

Operation and Care

Glass Cleaning Procedures

Safety Precautions for Glass Cleaning

Warns against using abrasive cleaners and cleaning hot glass.

Appliance Maintenance

Inspection and Cleaning Requirements

Stresses the need for regular inspection and cleaning by technicians and homeowners.

Servicing Safety Precautions

Mandates turning off gas and electrical power before servicing.

Front Glass Panel Removal and Installation

Safety Warnings for Glass Panel

Emphasizes crucial safety warnings related to the glass enclosure panel.

Procedure for Glass Panel Removal

Procedure for Glass Panel Installation

Burner Adjustments and Flame Appearance

Air Shutter Adjustment Procedure

Log Placement Guide

Log Handling and Safety Warnings

Provides safety warnings regarding hot logs and not burning wood.

Wiring Diagrams and Safety

Millivolt Gas Valve Lighting Instructions

Pilot Lighting Procedure

Step-by-step instructions for safely lighting the pilot on Millivolt gas valves.

Procedure to Turn Off Gas

Instructions for safely shutting off gas to the appliance.

Electronic Ignition System Lighting

Safety Warnings Before Lighting

Crucial safety warnings to follow before lighting the electronic ignition system.

Gas Leak Detection and Actions

Provides guidance on what to do if you smell gas.

Electronic Ignition Lighting Procedure

Step-by-step instructions for lighting the electronic ignition system.

Procedure to Shut Off Electronic System

Instructions for safely shutting off the electronic ignition system.

Troubleshooting Millivolt Gas Control System

Ignitor Not Lighting Pilot

Troubleshooting steps for when the spark ignitor does not light the pilot.

Pilot Not Staying Lit

Troubleshooting steps for when the pilot fails to remain lit after ignition.

Pilot Lit, No Burner Gas

Frequent Pilot;Burner Outages

Troubleshooting Electronic Ignition System

Burner Will Not Light

Troubleshooting steps for when the burner fails to ignite.

Burners Come On But Go Off

Electronic Ignition System Flowchart

Replacement Parts Identification

Superior DR-600CMN Specifications

General

Brand	Superior
Model	DR-600CMN
Category	Indoor Fireplace
Language	English