Superior DR-800CMP - User Manual

1
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 725,032M REV. H 11/2004
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
DIRECT-VENT
500/600/800 SERIES
MODELS
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
DR-500 MODEL SHOWN
sledoMtlovilliMsledoMcinortcelE
NMC005-DPMC006-TDNEC005-DPEC006-TD
PMC005-DNMC006-RDPEC005-DNEC006-RD
NMC005-TDPMC006-RDNEC005-TDPEC006-RD
PMC005-TDNMC008-DPEC005-TDNEC008-D
NMC005-RDPMC008-DNEC005-RDPEC008-D
PMC005-RDNMC008-TDPEC005-RDNEC008-TD
NMC006-DPMC008-TDNEC006-DPEC008-TD
PMC006-DNMC008-RDPEC006-DNEC008-RD
NMC006-TDPMC008-RDNEC006-TDPEC008-RD
OTL Report No. 116-F-13-4

Summary

General Information and Safety

Appliance Compliance and Critical Warnings

Appliance compliance with safety standards and critical warnings about appliance use.

Introduction to Operation and Controls

Gas Controls and Compartment Access

Maintenance Schedule

Annual Maintenance Tasks

Tasks to be performed annually by qualified technicians and homeowners.

Periodic Maintenance Tasks

Panel and Burner Adjustments

Front Glass Enclosure Panel Operations

Burner Flame Appearance and Sooting

Wiring Diagrams and Warranty

Wiring Diagrams Overview

Millivolt Gas Valve Lighting Instructions

Millivolt Lighting Safety Precautions

Essential safety information to read before attempting to light the appliance.

Millivolt Lighting Procedure

Step-by-step guide for lighting millivolt gas valves safely and correctly.

Electronic Ignition Lighting Instructions

Electronic Lighting Safety Precautions

Essential safety information for lighting electronic ignition appliances.

Electronic Lighting Procedure

Step-by-step guide for lighting electronic ignition systems safely.

Millivolt Gas Control System Troubleshooting

Millivolt Troubleshooting Symptoms and Causes

Common problems and their potential causes for millivolt gas control systems.

Millivolt Troubleshooting Corrective Actions

Recommended solutions for addressing millivolt system troubleshooting issues.

Electronic Ignition System Troubleshooting

Electronic Troubleshooting Symptoms and Causes

Common problems and their potential causes for electronic ignition systems.

Electronic Troubleshooting Flowchart

Flowchart for diagnosing and correcting electronic ignition system issues.

Replacement Parts List

General Fireplace Assemblies and Parts

SIT Millivolt Gas Controls Parts

Honeywell Millivolt Gas Controls Parts

Electronic Gas Controls Parts

Superior DR-800CMP Specifications

General

Model	DR-800CMP
Category	Indoor Fireplace
Type	Direct Vent Gas Fireplace
Fuel Type	Natural Gas or Propane
Ignition	Electronic Ignition
Burner Material	Stainless Steel
Log Set Material	Ceramic Fiber
Venting	Direct Vent
Warranty	Limited Lifetime