Suzuki df2.5 - Page 4

GENERALINFORMATION 1-3
CAUTION
• If parts replacement Is necessary, replace the parts with Suzuki Genuine Parts or their equiv-
alent .
• When removing parts that are to be reused, keep them arranged in an orderly manner so that
they may be reinstalled in the proper order and orientation .
• Be sure to use spec ial tools when i nstructed .
• Make sure that all parts used in assembly are clean and also lubricated when specified.
• When use of a certain type of lubr i cant , bond, or sealant is specified, be sure to use the spec -
ified type .
• When removing the battery, disconnect the negative cable first and then the pos it i ve cable.
When reconnecting
the battery , connect the positive cable first and then the negative cable.
• When performing service to electr ical parts, if the service procedures do not require us i ng
battery power, disconnect the negat i ve cable from the battery.
• Tighten cylinder head and case bolts and nuts , beginning with larger diameter and ending
wi th smaller diameter. Always tighten from inside to outside diagonally to the specified tight-
eni ng torque .
• Whenever you remove oil seals , gaskets, packing , 0-rings , locking washers, locking nuts ,
cotter pins, circljps, and certain other parts as specified, always replace them with new. Also,
before. installing these new parts, be sure to remove any left over material from the mating
surfaces.
• Never reuse a circlip . When installing a new circlip, take care not to expand the end gap larger
than required to slip the circllp over the shaft . After Installing a circlip, always ensure that it is
completely seated in I ts groove and securely fitted.
• Use a torque Wrench to tighten fasteners to the specified torque.
Wipe off grease and oil it a threads is smeared with them.
• After reassembly, check parts for ti ghtness and proper operation .
• To protect the environment , do not unlawfully dispose of used motor oil, other fluids, and bat-
teries.
• To protect the Earth's natural resources, properly dispose of used motor and parts.