(Please refer to the components location diagram for the following components.)
ROUTINE INSPECTION
Check Items Check Key Points
Engine Oil Is there enough engine oil?
Fuel Is it enough? Is it Octane 90 or above
Front
Braking condition?
(Brake lever free play: 10~20mm)
Brake
Rear
Braking condition?
(Brake lever free play: 10~20mm)
Front
Is tire pressure normal?
(Standard: 1.5kg/cm
2
)
tires
Rear
Is tire pressure normal?
(Standard: 2.25 kg/cm
2
for 1 person, 2.5 kg/cm
2
for 2 persons)
Steering Handle Does the handle vibrate abnormally or is difficult to turn?
Speedometer, lights,
and rearview mirror
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Tightness of Main
Components
Are screws, nuts loosen?
Abnormal Points Do the previous troubles still exist?
CAUTION:
• If any problem founded during routine inspection, correct the problem before using the scooter again,
have your scooter checked and repaired by the “SYM dealer or authorized service personnel” if
necessary.
ENGINE OIL INSPECTION AND CHANGE
INSPECTION:
1. Use the main parking stand to support the scooter on a level ground, remove the dipstick after engine
stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do not
rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase…etc for leakage.)
OIL CHANGE:
• Change engine oil after the first 300km, and change the engine oil
every 3,000km thereafter. Clean oil filter after the first 300km, and
clean oil filter every 6,000km.
• In order to maintain the engine’s maximum performance, check
whether the engine oil is enough every 1,000km. Add oil to upper
limit if the engine oil has been found to be inadequate.
17
10. Inspection and maintenance before riding
• Engine Oil : Use API SH, SAE 10w-40 grade or better engine oil.
Otherwise, damage will not be covered by warranty.
※ Recommended Oil: SYM Genuine EXTRA 4X OIL.
• Oil Capacity :
GTS 300/250：1.4 Liter (1.2 liters for routine change),
oil filter change: 1.2 liters.
GTS 125：1.0 Liter (0.8 liters for routine change),
oil filter change: 0.8 liters.
Upper
Lower
To Next Page
Loading...
Need help?
General
