TTHHDDC C / / TTHHDDCCP P - - 99554 4 / / 99555 5 / / 99774 4 ((RReevv. . 0066//0033) ) SSaaffeettyy--33
exhaust all air from a single tire and both tiresexhaust all air from a single tire and both tires
of a dual assembly prior to removing any rimof a dual assembly prior to removing any rim
components or wheel components such ascomponents or wheel components such as
nuts and rnuts and rim clampim clamps. s. Run a piece of Run a piece of wirewire
through the valve stem to make sure the valvethrough the valve stem to make sure the valve
stem is not damaged or plugged and all air isstem is not damaged or plugged and all air is
exhausted.exhausted.
WARNING:WARNING: Serious falls and injuries canSerious falls and injuries can
result from improper mounting or dismountingresult from improper mounting or dismounting
of the of the containcontainer er handlihandling truck.ng truck.
Mounting and Dismounting:Mounting and Dismounting:
1. 1. FacFace the contae the container hainer handlindling trucng truck when getk when get--
ting on or off the truck.ting on or off the truck.
2. 2. One hand aOne hand and twnd two feet oo feet or twr two hands o hands and oneand one
foot must be in contact with the truck at allfoot must be in contact with the truck at all
times (3 point contact).times (3 point contact).
3. 3. Use haUse handrandrails ails and other gnd other grab poirab points.nts.
WARNING:WARNING: Do not start the engine if theDo not start the engine if the
ignitignition switch, or ion switch, or engine control panel hasengine control panel has
been locked-out / been locked-out / tagged-tagged-out by out by maintenmaintenanceance
personnpersonnel. el. Doing so can resuDoing so can result in personlt in personalal
injurinjury and / or damage to the equy and / or damage to the equipmentipment. . If inIf in
doubt, contact the maintenance supervisor.doubt, contact the maintenance supervisor.
WARNING:WARNING: If maintenance requires run-If maintenance requires run-
ning the engine indoors, ensure the room hasning the engine indoors, ensure the room has
adequate flow-through ventilation!adequate flow-through ventilation!
WARNING:WARNING: Never operate the containerNever operate the container
handling truck without proper instruction.handling truck without proper instruction.
IgnorIgnorance ance of operational characteristiof operational characteristics cs andand
limitatlimitations can ions can lead to lead to equipequipment damage,ment damage,
personal injury, or death.personal injury, or death.
WARNING:WARNING: Do not operate the containDo not operate the containerer
handlihandling truck ng truck withowithout the ut the seat belt seat belt propproperlyerly
and securely fastened.and securely fastened.
WARNING:WARNING: Operating instructions, warn-Operating instructions, warn-
ings, and caution labels are placed on the con-ings, and caution labels are placed on the con-
tainer handling truck to alert personnel to dan-tainer handling truck to alert personnel to dan-
gers and to advise personnel of propergers and to advise personnel of proper
operatioperating procedng procedures (of the lift trures (of the lift truck). uck). Do notDo not
remove or obscure any warning, caution, dan-remove or obscure any warning, caution, dan-
ger, or instructional sign or label.ger, or instructional sign or label.
Traveling:Traveling:
Start, stop, change direction and travel smoothly.Start, stop, change direction and travel smoothly.
Slow down while turning.Slow down while turning.
Obstructions And Clearances:Obstructions And Clearances:
Watch end clearances and overhead obstructions.Watch end clearances and overhead obstructions.
WARNING:WARNING: Do not release the parkingDo not release the parking
brake or attempt to move the container han-brake or attempt to move the container han-
dling truck if the air pressure gauge indicatesdling truck if the air pressure gauge indicates
that the air pressure is below 100 psi.that the air pressure is below 100 psi.
WARNING:WARNING: Make sure all ground person-Make sure all ground person-
nel know the rules and responsibilities set bynel know the rules and responsibilities set by
your emplyour employeroyer. . Make sure they know what youMake sure they know what you
are going to do and be sure they are clear ofare going to do and be sure they are clear of
the area before you move the container han-the area before you move the container han-
dling truck.dling truck.
WARNING:WARNING: Cameras are not substitutesCameras are not substitutes
for looking in the direction of and keeping afor looking in the direction of and keeping a
clear vieclear view of the path of traw of the path of travel. vel. NeveNever user use
them as them as substisubstitutes,tutes,AlwaysAlwayslook in the path oflook in the path of
travel.travel.
WARNING:WARNING: Total reliance on electricalTotal reliance on electrical
aids can be dangeroaids can be dangerous. us. The responThe responsibilisibility forty for
safe safe operatoperation of ion of the container handling truckthe container handling truck
shall remain with the operator who shallshall remain with the operator who shall
ensure that all warning and instructions pro-ensure that all warning and instructions pro-
vided are fully understood and observed.vided are fully understood and observed.
WARNING:WARNING: Do not operate the containDo not operate the containerer
handlihandling truck ng truck until both forward and until both forward and reversereverse
travel pathtravel paths are clear. s are clear. Do not opDo not operate the truerate the truckck
with with bystandbystanders ers presentpresent..
WARNING:WARNING: Do not move the containerDo not move the container
handlihandling truck ng truck until the surroundiuntil the surrounding area ng area hashas
been checked and is clear of personnel andbeen checked and is clear of personnel and
obstructions.obstructions.
WARNING:WARNING: Always look in the directionAlways look in the direction
of travel and keep a clear view of the path ofof travel and keep a clear view of the path of
travel; travel; slow down and soslow down and sound the hound the horn at crossrn at cross
aisles and other locations where vision may beaisles and other locations where vision may be
obscured.obscured.
To Next Page
Loading...
Need help?
General
